以快速熱熔異質磊晶成長法製作鍺矽累增型光偵測器

以作者查詢圖書館館藏

、以作者查詢臺灣博碩士

、以作者查詢全國書目

、勘誤回報

、線上人數：113

、訪客IP：3.137.217.242

姓名

周晉賢(Chin-hsien Chou) 查詢紙本館藏

畢業系所

電機工程學系

論文名稱

以快速熱熔異質磊晶成長法製作鍺矽累增型光偵測器
(Silicon/Germanium Heterojunction Avalanche Photodetector by Rapid-Melting-Growth Technique)

相關論文

★ 以熱熔異質磊晶成長法製造之鍺光偵測器	★ 在SOI基板上以快速熱熔法製造高品質鍺及近紅外線光偵測元件之研製
★ 鉭錳合金及銅鍺化合物應用於積體電路後段製程中銅導線之研究	★ 快速熱熔磊晶成長法製造側向PIN(Ge-Ge-Si)光偵測器
★ 二維薄膜及三維塊材Seebeck係數量測	★ 塊材、薄膜與奈米線之熱導係數量測方法探討
★ 以快速熱熔融磊晶成長法製作鍺錫合金PIN型光偵測器	★ 利用火花電漿燒結法製備以矽為基底之奈米材料於熱電特性上之應用研究
★ P型金屬氧化物薄膜的製備應用於軟性電子	★ 金屬氧化物製備應用於軟性電子元件
★ 超導材料釔鋇銅氧化物熱電特性量測分析	★ 鎂矽錫合金熱電特性研究及應用
★ 矽基熱電模組開發及特性研究	★ P型金屬氧化物與硫化物之研究
★ 物聯網之熱感測器應用	★ P型金屬氧化物與硫化物合金薄膜之研究

檔案

[Endnote RIS 格式]

[Bibtex 格式]

[相關文章]

[文章引用]

[完整記錄]

[館藏目錄]

至系統瀏覽論文 ( 永不開放)

摘要(中)

近年來將鍺整合於矽基板上製做成電子元件與光電元件已逐漸成為趨勢，
利用鍺的高吸收係數、高電子電洞遷移率以及窄能帶的優點；矽的高電離係數，易解離出新的電子電洞對可做為累增型光偵測器的增益層，且可整合在CMOS製程上。而矽鍺之間有著4.2%的晶格不匹配其整合上有一定的難度。一般將鍺磊晶在矽基板的方法主要是使用昂貴的高真空磊晶機台如分子束磊晶(MBE)、超高真空化學氣相沉積(UHVCVD)…等等，以上機台製程上都非常昂貴且成長速度慢。
本論文使用快速熱熔融磊晶成長法製作單晶鍺，較一般高真空機台更簡單快速且可降低成本。在SOI 基板上進行兩次快速熱熔融磊晶成長法，第一層為50nm的鍺緩衝層；第二層為500 nm 的鍺吸收層，第一層的緩衝層能夠侷限鍺矽介面所產生的差排且可作為第二層鍺的晶種點，成長為高品質的鍺吸收層，並利用TEM、SEM 及Raman 光譜進行材料分析。最後製做為分離式吸收、電荷、累增層之鍺矽光測器，並量測其光暗電流及光響應度。

摘要(英)

Recently, silicon(Si)-based electronics integrated with germanium(Ge) are widely adopted due to the fact that Ge has a narrow band gap as absorption material for infrared wavelength and CMOS-compatible process, while Si has a favorable ionization coefficient ratio as avalanche multiplication material. However, it’s difficult to grow Ge on Si because of the large lattice mismatch (4.2%) between Si and Ge.Generally, epitaxial growth of Ge on Si relies on ultra-high vacuum chemical vapor deposition, which was expensive and time-consuming.
In this report, we used rapid-melting-growth method to grown high-quality Ge on SOI (silicon-on-insulator), and then we can obtain a high-quality Ge absorption layer. Defect analysis was conducted by TEM, SEM and Raman Spectrometer.Furthermore, the SACM Ge/Si avalanche photodetector by rapid-melting-growth was fabricated and measured I-V characteristics of the fabricated device were studied.

關鍵字(中)

★ 矽鍺
★ 累增型光偵測器
★ 快速熱熔

關鍵字(英)

★ Silicon/Germanium
★ Avalanche Photodetector
★ Rapid-Melting-Growth

論文目次

目錄
中文摘要 i
英文摘要 ii
致謝 iii
目錄 iv
第一章簡介 1
1-1 論文架構 1
1-2 光纖通訊基本架構 1
1-3 本論文研究動機及目的 3
第二章使用快速熱異質磊晶成長法製作分離式吸收、電荷、累增之鍺矽光偵測
器的設計原理 4
2-1 鍺矽光偵測器應用 4
2-2 鍺矽光偵測器應用 5
2-3 光偵測器的特性參數 9
2-4 分離式吸收、電荷、累增之鍺矽光偵測器 10
2-5 快速熱熔磊晶成長 14
2-6 實驗設計 16
第三章使用快速熱熔異質磊晶成長法製作分離式吸收、電荷、累增之鍺矽光偵
測器的製成步驟 19
3-1 前言 19
3-2 製程步驟與細節 23
3-3 元件製程流程表 33
第四章元件材料分析與電性量測分析 40
4-1 快速熱熔磊晶成長法材料分析 40
4-1-1 實驗一: 不使用晶種視窗區下進行熱熔成長法 40
4-1-2 實驗二:兩段式快速熱熔磊晶成長法 49
4-2 元件量測分析 53
第五章結論與未來展望 57
參考文獻 58

參考文獻

[1] 王心平,“利用射頻技術實現混合乙太數位及射頻訊號之單波長光纖通訊系統”,國立中央大學通訊研究所論文,1995.
[2] Binu,“ Fiber Optic Communication System”,Technology, April,2009.
[3]洪富城,“採用累增崩潰異質接面光電晶體和衝渡二極體兩種元件來改善增益頻寬積的特性”, 國立中央大學通訊研究所論文,2008.
[4] G. Dehlinger, S. J. Koester, Senior Member, J. D. Schaub, Member, J. O. Chu, Q.C. Ouyang, Member, and A. Grill,“High-Speed Germanium-on-SOI Lateral PIN Photodiodes”, IEEE PHOTONICS TECHNOLOGY LETTERS, VOL. 16, NO. 11,NOVEMBER 2004.
[5] Yasuhiko Ishikawa, Sungbong Park, Jiro Osaka, and Kazumi Wada,“Low-Dark-Current pin Photodiodes Using As-Grown Ge with an i-Si Insertion Layer: Mechanism of Dark Current Suppression”, Group IV Photonics, 2009. GFP
′09. 6th IEEE ,pp.22-24, 9-11 Sept. 2009
[6] Richard S. Quimby,“Photonics and Lasers”, John Wiley & Sons, Inc.,2006.
[7]張守進、楊勝州,“以高功函數的金屬鈀研製氧化鋅金半金光檢測器”,國立成功大學為電子工程研究所,Jan,2007.
[8]李姿瑩,“標準CMOS製程之850nm矽累崩光檢測器” ,國立中央大學通訊研究所論文,2012.
[9] 黃柏涵, “ Silicon/Germanium Heterojunction Photodetector by Rapid-Melting-Growth Techniqe” ,國立中央大學通訊研究所論文,2014.
[10] Xiaoxin Wan, Liang Chen, Wang Chen, Hailin Cui, Yan Hu, Pengfei Cai, Rong Yang,Ching-Yin Hong, Dong Pan, Kah-Wee Ang, Ming Bin Yu, Qing Fang and Guo Qiang Lo,“80 GHz bandwidth-gain-product Ge/Si avalanche photodetector by
selective Ge growth”, Optical Fiber Communication - incudes post deadline papers,pp.1-3,2009.
[11] Yimin Kang, Stas Litski, Gadi Sarid, Mike Morse, and Mario J. Paniccia,Alexandre Pauchard, Kian Giap Gan and John E. Bowers, “Ge/Si Avalanche Photodiodes for 1.3μm Optical Fiber Links”, Group IV Photonics, 2007 4th IEEE,
pp.1-3, 19-21 Sept. 2007.
[12] Ning Duan, Tsung-Yang Liow, Andy Eu-Jin Lim, Liang Ding and G. Q. Lo, “310GHz Gain-Bandwidth Product Ge/Si Avalanche Photodetector by Selective Epitaxial Growth”, vol. 20,Issue 10, pp.11031-11036 ,2012
[13] John E. Bowers , Daoxin Dai , Yimin Kang , and Mike Morse,“High-gain high-sensitivity resonant Ge/Si APD photodetectors”, SPIE Vol. 7660 76603H 1-8 ,2010
[14] K. Yamada, T. Tsuchizawa, T. Watanabe, R. Kou, H. Nishi, H. Shinojima, Y. Ishikawa, K. Wada and S. Itabashi,“ Avalanche-mode operation of a simple vertical
p-i-n germanium photodiode coupled with a silicon waveguide ” , Group IV Photonics (GFP), 2011 8th IEEE , pp.329-331,2011
[15]莫秋燕、趙彥立,“光通信用雪崩二極管(APD)頻率響應特性研究”,Acta Phys Sin Vol 60, No. 7, 2011.
[16] VOXTEL OPTO,“Separate absorption, charge, and multiplication(SACM) Avalanche Photodiode Design”, TECHNICAL NOTE: V805.
[17]Qiniing Li,Darin Leonhardt, Joshua L. Krauss, Stephen Hersee, and Sang M. Han,
“Selective MBE of High-Quality Ge on Si Covered with Si02”, SiGe Technology and Device Meeting, 2006. ISTDM 2006. Third International, pp.1 – 2, 15-17 May 2006
[18] Keun Wook Shin and Euijoon Yoon,“Epitaxial Ge growth on Si(001) substrates and in-situ doping using UHV-CVD”, Group IV Photonics (GFP), 2013 IEEE 10th , pp. 41 – 42, 28-30 Aug. 2013
[19] Byongju Kim , Hyunchul Jang , Dae-Seop Byeon , Sangmo Koo , and Dae-Hong Ko,“Observation of in situ B-doped Epitaxial Ge Layer Growth on Si(111) by
Ultra-high Vacuum Chemical Vapor Deposition”, Silicon-Germanium Technology and Device Meeting (ISTDM), 2014 7th International, pp.77 – 78, 2-4 June 2014.
[20] Dongwoo Suh, Jiho Joo, Sanghoon Kim, and Gyungock Kim,“High-Speed RPCVD Ge Waveguide Photodetector”, Group IV Photonics, 2009. GFP ′09. 6th IEEE International Conference , pp. 16 – 18, 9-11 Sept. 2009
[21] Yaocheng Liu, Michael D. Deal, and James D. Plummer, “High-quality single-crystal Ge on insulator by liquid-phase epitaxy on Si substrates” , Appl. Phys. Lett. 84, 2563 (2004)
[22] T. Sadoh and M. Miyao,“High-Mobility Ge on Insulator (GOI) by SiGe Mixing-Triggered Rapid-Melting-Growth”, ECS, volume 33, issue 6,409-418 ,2010
[23]Kah-Wee Ang, Joseph Weisheng Ng, Andy Eu-Jin Lim, Ming-Bin Yu, Guo-Qiang Lo, and Dim-Lee Kwong,“Waveguide-Integrated Ge/Si Avalanche Photodetector with 105GHz Gain-Bandwidth Product” , Optical Fiber Communication (OFC),pp. 1 – 3, 21-25 March 2010
[24] Ning Duan, Tsung-Yang Liow, Andy Eu-Jin Lim, Liang Ding, and Guo Qiang Lo, “High Speed Waveguide-Integrated Ge/Si Avalanche Photodetector”, Optical Fiber Communication Conference and Exposition and the National Fiber Optic Engineers Conference (OFC/NFOEC), 2013, pp. 1 – 3, 17-21 March 2013
[25] 工業技術研究院材料與化工研究所,羅聖全,“電子顯微鏡介紹-SEM”,小微米大世界.
[26 ] 林明為、羅聖全、朱仁佑、蔡枝松、林麗娟、葉吉田,“雙粒子束聚焦式離子束(DB-FIB) 技術在材料檢驗分析上之應用與發展” , 工業材料雜誌,252期,Dec,2007.
[27] 工業技術研究院材料與化工研究所,羅聖全,“電子顯微鏡介紹-TEM”, 小微米大世界.
[28] N. R. Rueger, M. F. Doemling, M. Schaepkens, J. J. Beulens, T. E. F. M.Standaert,and G. S. Oehrlein,“Selective etching of SiO2 over polycrystalline silicon using CHF3 in an inductively coupled plasma reactor” , J. Vac. Sci. Technol. A, Vol. 17, No. 5, Sep/Oct 1999.
[29] 許育銓,“鍺量子點共振穿隧二極體與電晶體之關鍵製成模組開發與元件特性”,國立中央大學通訊研究所論文,2006
[30] Ning Duan, Tsung-Yang Liow, Andy Eu-Jin Lim, Liang Ding, and Guo Qiang Lo,“High Speed Waveguide-Integrated Ge/Si Avalanche Photodetector”, Optical Fiber Communication Conference and Exposition and the National Fiber Optic Engineers Conference (OFC/NFOEC), 2013, pp. 1 – 3, 17-21 March 2013

指導教授

辛正倫(Cheng-Lun Hsin)

審核日期

2015-11-11

推文