![]() |
|
以作者查詢圖書館館藏 、以作者查詢臺灣博碩士 、以作者查詢全國書目 、勘誤回報 、線上人數:35 、訪客IP:18.119.19.229
姓名 黃茂順(Mao-shun Huang) 查詢紙本館藏 畢業系所 電機工程學系 論文名稱 溝槽式鍺奈米晶粒快閃記憶體單胞元的製作
(Fabrication of Ge Nanocrystal Flash Memory Cells with Trench Structure)相關論文 檔案 [Endnote RIS 格式]
[Bibtex 格式]
[相關文章]
[文章引用]
[完整記錄]
[館藏目錄]
[檢視]
[下載]
- 本電子論文使用權限為同意立即開放。
- 已達開放權限電子全文僅授權使用者為學術研究之目的,進行個人非營利性質之檢索、閱讀、列印。
- 請遵守中華民國著作權法之相關規定,切勿任意重製、散佈、改作、轉貼、播送,以免觸法。
摘要(中) 論文提要
本論文的主題是研製具有溝槽式結構的鍺奈米晶粒快閃記憶體單胞元。首先利用TMAH溶液對(100)晶向的矽晶圓進行蝕刻,形成凹陷的溝槽結構,然後藉由乾式氧化成長氧化層在矽基板上,之後以電漿助長化學氣相沉積系統沉積非晶矽/非晶矽鍺/非晶矽多層膜,再以高溫爐管進行氧化處理,形成鍺奈米晶體包埋在氧化層內;鍺奈米晶體的形成是利用矽鍺合金中的矽與鍺在高溫氧化速率不同,鍺原子會自氧化物釋放出來並埋藏在氧化物與矽鍺合金介面的特性,利用此技巧可製造奈米尺寸的鍺奈米晶體。本研究引用此技巧將鍺奈米晶體成長在溝槽側壁,利用製程自然地將儲存媒介分立,以期能得到多位元的快閃記憶體單胞元。
為探討單胞元的電荷儲存特性,研究時亦首先製作金屬-氧化層-半導體電容結構,藉由電容-電壓量測得知元件的記憶窗口大小約為0.25伏特。接著藉由電流-電壓量測雙位元記憶體單胞元的IDS-VGS特性曲線圖,發現臨界電壓有偏移的效果,記憶窗口大小最大約為12.5伏特。希冀以此具有溝槽結構的鍺奈米晶體快閃記憶體單胞元可應用在未來的記體體工業中。摘要(英) Abstract
In this thesis, the Ge nanocrystal flash memory cells with trench structure have been fabricated and demonstrated. Firstly, the trench structure was formed by etching of (100) silicon wafer with TMAH solution. Then, oxide was grown on the Si substrate with a dry oxidation process. After that, the amorphous silicon (a-Si)/amorphous silicon germanium (a-SiGe)/a-Si multilayer were prepared with a plasma- enhanced chemical vapor deposition system. Finally, the a-Si/a-SiGe/a-Si multilayers were thermally oxidized by using a high-temperature furnace to form the Ge nanocrystals. The nano-meter scale Ge crystal dots were formed by Ge segregation and agglomeration during the SiGe oxidation process. It was expected that the multi-bit operation of flash memory cells could be obtained by the charge storage medium of Ge nanocrystals formed on the sidewalls of trench accordingly.
In order to investigate the charge storage phenomenon of the formed Ge nanocrystals, the metal-oxide-semiconductor (MOS) capacitors with Ge nanocrystal embedded in oxide matrix were also fabricated. It has been found that a memory window of 0.25 V could be obtained, from the C-V measurements of the MOS capacitors. From the measured IDS-VGS curves of two-bits memory cells, a wide memory window of about 12.5 V was obtained. The Ge-nanocrystals flash-memory cells with trench structure could be a promising candidate in future flash memory application.關鍵字(中) ★ 鍺量子點
★ 快閃記憶體關鍵字(英) ★ flash memory
★ Ge nanocrystal論文目次 Contents
Table Captions………………………………………………… ..Ⅲ
Figure Captions………………………………………..……… ..Ⅳ
Chapter 1 Introduction…...…………………………………...1
Chapter 2 Motivation and Device Operation rinciples…...4
2.1 Motivation…………………………………......4
2.1.1 Quantum confinement effect [3]………....4
2.1.2 Comparison between Ge and Si quantum
dots…..................................6
2.1.3 Formation of Ge quantum-dots…………....6
2.1.4 Effects of Ge concentration……………...8
2.2 Operation principles of nonvolatile
memory…..................................12
2.2.1 Basic program mechanisms………………...12
2.2.2 Basic erasing mechanisms………………...13
Chapter 3 Device Fabrication and Measurement
Techniques….................................18
3.1 Device Fabrication…………………………....18
3.2 MeasurementTechniques…….................31
3.2.1 Transmission electron microscopy (TEM).31
3.2.2 Scanning electron microscopy (SEM)…….31
3.2.3 Micro-Raman spectroscopy………………….31
3.2.4 Capacitance-Voltage meter…………………32
Chapter 4 Experimental Results and Discussion……………33
4.1 The formation of groove structure………….33
4.2 The Characterization of Ge nanocrystals….37
4.2.1 Scanning electron microscopy (SEM)…….37
4.2.2 Raman scattering spectra………………….43
4.2.3 Transmission electron microscopy (TEM).45
4.3 C-V measurements of MOS capacitors…………46
4.4 I-V measurements of two-bits cell………….54
4.5 Operation of two-bits………………………….63
Chapter 5 Conclusion…………………………………………….71
References………………………………………………………….73參考文獻 References
[1] J. De Blauwe, “Nanocrystal Nonvolatile Memory Devices,” IEEE Trans. Nanotechnol., vol. 1, No. 1, pp. 72-77, 2002.
[2] C. H. Tu, T. C. Chang, P. T. Liu, H. C. Liu, S. M. Sze, and C. Y. Chang, “Improved Memory Window for Ge Nanocrystals Embedded in SiON Layer,” Appl. Phys. Lett., vol. 89, 162105, 2006.
[3] J. Singh, “Electronic and Optoelectronic Properties of Semiconductor Structures,” chap. 3, pp. 125-127, 2003.
[4] Y. Maeda, “Visible Photoluminescence from Nanocrystallite Ge Embedded in A Glassy SiO2 Matrix: Evidence in Support of the Quantum Confinement Mechanism,” Phys. Rev. B vol. 51, pp. 1658, 1995.
[5] K. V. Shcheglov, C. M. Yang, K. J. Vahala, and Harry A. Atwater “Electroluminescence and Photoluminescence of Ge-implanted Si/SiO2/Si structures,” Appl. Phys. Lett., vol. 66, pp. 745-747, 1995.
[6] J. Y. Zhang, Y. H. Yea and X. L. Tan, “Electroluminescence and Carrier Transport of SiO2 Film Containing Different Density of Ge Nanocrystals,” Appl. Phys. Lett., vol. 74, pp. 2459-2461, 1999.
[7] W. K. Choi, Y. W. Ho, S. P. Ng, and V. Ng, “Microstructural and Photoluminescence Studies of Germanium Nanocrystals in a Amorphous Silicon Oxide Films,” J. Appl. Phys., vol. 89, pp.2168-2172, 2001.
[8] Z. He, J. Xu, W. Li, K. Chen, and D. Feng, “Crystallization and Oxidation Process of nc-Ge in a- SiO2 Matrix from a-Si:H/a-Ge:H Multilayers,” J. of Non-Crystalline Solids, vol. 266-269, pp. 1025-1028, 2000.
[9] P. E. Hellberg, S. L. Zhang, F. M. d’Heurle, and C. S. Petersson, “Oxidation of Silicon-germanium Alloys. I. An experimental study,” J. Appl. Phys., vol. 82, pp. 5773-5778, 1997.
[10] P. W. Li, W. M. Liao, S. W. Lin, P. S. Chen, S. C. Liu and M. J. Tsai, “Formation of Atomic-scale Germanium Quantum Dots by Selective Oxidation of SiGe/Si-on-insulator,” Appl. Phys. Lett., vol. 83, pp. 4628-4630, 2003.
[11] W. K. Choi, V. Ng, S. P. Ng, and H. H. Thio, “Raman Characterization of Germanium Nanocrystals in Amorphous Silicon Oxide Films Synthesized by Rapid Thermal Annealing,” J. Appl. Phys., vol. 86, pp. 1398-1403, 1999.
[12] P. J. Wu, “Ge Quantum-Dots Formed by Selective Oxidation of a-Si:H/a-SiGe:H Multilayer and Fabrication of Ge Quantum-Dots MSM Photodetectors,” M. S. Thesis, NCU, Taiwan, R.O.C., 2006.
[13] H. K. Liou, P. Mei, U. Gennser, and E. S. Yang, “Effects of Ge Concentration on SiGe Oxidation Behavior,” Appl. Phys. Lett., vol.59, pp. 1200-1202, 1991.
[14] M.Lenzlinger, “Fowler-Nordheim Tunneling in Thermal Grown SiO2,” J. App. Phys., vol. 40, p.278, 1969.
[15] Y. W. Huang, “Nanocrystalline Si P-I-N Solar Cell,” M. S. Thesis, NCU, Taiwan, R.O.C., 2007.
[16] O. Tabata, “Anisotropic Etching of Si in TMAH Solutions,” Sensor and Actuators A, vol. 34, p. 51, 1992.
[17] T. Hiramoto, “Nano-scale Silicon MOSFET: Towards Non-Traditional and Quantum Devices,” 2001 IEEE International SOI Conference, p. 8, 2001.
[18] Min-Chuan Wang, “Study on Ge Quantum Dots Application for Memory and Optoelectronic Devices,” M. S. Thesis, NSYU, Taiwan, R.O.C., 2003.μm指導教授 洪志旺(Jyh-Wong Hong) 審核日期 2008-7-11 推文 plurk
funp
live
udn
HD
myshare
netvibes
friend
youpush
delicious
baidu
網路書籤 Google bookmarks
del.icio.us
hemidemi
myshare