使用等效簡化扣件組模型之軌橋互制行為分析

以作者查詢圖書館館藏

、以作者查詢臺灣博碩士

、以作者查詢全國書目

、勘誤回報

、線上人數：127

、訪客IP：3.15.168.20

姓名

劉妍麟(Yen-Lin Liu) 查詢紙本館藏

畢業系所

土木工程學系

論文名稱

使用等效簡化扣件組模型之軌橋互制行為分析
(Track-Bridge Interaction Analysis Using Simplified Effective Fastener Model)

相關論文

★ 貼片補強構件之層間應力分析	★ 軌道不整檢測及識別方法
★ 混凝土結構分析之三維等效單軸組成材料模型	★ 卵形顆粒法向與切向接觸之等效線性彈簧值之推導與驗證
★ 以四面體離散化多面體系統之接觸分析與模擬	★ 軌道車輛三維動態脫軌係數之在線量測理論
★ 向量式DKMT厚殼元推導與模擬	★ 向量式預力混凝土二維剛架元之數值模擬與驗證
★ 向量式有限元應用於懸索橋非線性動力分析	★ 蛋形顆粒群之流固耦合分析
★ 複合版梁元素分析模型之橋梁動態識別法	★ 三維等效單軸應變與應力之材料組成模型
★ 人行吊橋的現有內力評估及動力分析	★ 薄殼結構非線性運動之向量式有限元分析法
★ 雷射掃描技術於鋼軌磨耗之檢測	★ 動態加載下的等效單軸應變與應力材料組成模型

檔案

[Endnote RIS 格式]

[Bibtex 格式]

[相關文章]

[文章引用]

[完整記錄]

[館藏目錄]

至系統瀏覽論文 (2025-8-1以後開放)

摘要(中)

當軌道與橋梁互制作用影響時，鋼軌扣件系統必須有效束制鋼軌移動，若扣件系統中有組件破損，則會大幅增加鐵路上的養護成本。本研究主要探討現地三種不同路段之行為模式，分別為平直段、陡坡段與曲線段，路段中有鋼軌墊片與基鈑墊片大量破損問題，故此研究旨在發展一套能快速而精確模擬軌橋互制行為的數值分析模型，且根據鋼軌扣件組行為以LS-Dyna進行詳細3D接觸動力行為的模擬分析結果，以有限元素軟體SAP2000使用剛架與彈簧元素建立精確分析之等效簡化扣件組模型，依據欲分析之不同路段行為提出相應簡化程度之模型，應用於現地橋梁與軌道系統當中，探討長區段軌橋系統在溫度荷載、列車荷載、扣件組螺栓鎖固力等等外力載重產生之行為變化，並與現地檢監測數據做比對驗證，確保模型正確性，然而找出墊片破壞的可能原因與範圍並研擬可行之改善方法，將來可作為大尺度軌道橋梁數值模擬分析的參考依據，具經濟性及效益性。

摘要(英)

The rail fastening system must effectively fix the rails due to the track- bridge interaction. If any component in the rail fastening system is damaged, it will greatly increase the maintenance cost of the railway. This research mainly discusses the behavior patterns of three different spans, namely straight span, steep slope span and curved span. There are a large number of damage to rail pads and intermediate pads in the spans. Therefore, the research progresses to develop a set of numerical analysis models that can quickly and accurately simulate the behavior of track-bridge interaction. Based on the behavior results of the rail fastening system that use LS-Dyna to perform detailed 3D contact dynamic behavior simulation analysis. From the results, use the finite element software SAP2000 establish an equivalent simplified fastener model for accurate analysis by rigid frame and spring elements , propose corresponding simplified model based on the behavior of different segments to be analyzed. Replace it on field track-bridge system and discuss the behavioral changes of the rail bridge system under external load such as temperature change , train moving load, fastener bolt locking force, and so on. In addition, finite element analysis was conducted and the results were compared with the measured track-bridge interaction response. Find out the possible cause and the influence area of pad damage then develop feasible improvement methods. In the future, it can be used as a reference basis for numerical simulation analysis of large-scale rail bridges, which is economical and beneficial.

關鍵字(中)

★ 鋼軌扣件系統
★ 軌橋互制行為
★ 墊片破壞
★ 現地監測
★ SAP2000

關鍵字(英)

★ Rail fastening system
★ Track-bridge interaction
★ Pad damage
★ Field measurement
★ SAP2000

論文目次

摘要 I
Abstract II
誌謝 III
目錄 IV
圖目錄 VII
表目錄 XIV
第一章緒論 1
1.1研究動機與目的 1
1.2研究方法與論文架構 2
第二章文獻回顧 5
2.1長焊鋼軌理論及相關規定 5
2.1.1鋪設條件 6
2.1.2鋪定溫度 6
2.1.3橋上長焊鋼軌受溫度變化之軸力分析 8
2.2軌道與橋梁互制文獻探討 9
2.3鋼軌扣件組行為模擬文獻探討 12
第三章鋼軌扣件組簡化模擬分析 14
3.1鋼軌扣件組簡化模型構想 14
3.2鋼軌扣件系統介紹 14
3.3扣件組之簡化力學模型 17
3.4扣件組行為說明與參數設定 18
第四章橋梁與軌道系統靜力模擬分析 27
4.1軌橋數值模型分析案例探討及分析流程 27
4.2軌橋互制行為監測說明 27
4.2.1溫度數據整理 30
4.2.2鋼軌軸力數據計算 30
4.3 平直段軌橋互制行為數值模擬分析 34
4.3.1軌橋結構 34
4.3.2分析模型參數設定 36
4.3.3監測數據與數值模擬分析方法比對說明 40
4.3.4 大梁伸縮縫相對位移量數值模擬分析 42
4.3.5道版與鋼軌相對位移數值模擬分析 43
4.3.6鋼軌與鋼軌墊片相對位移數值模擬分析 45
4.3.7鋼軌軸力數值模擬分析 47
4.3.8鋼軌初始應力狀態推算 49
4.3.9鋼軌墊片破壞區間探討 54
4.3.10 ST-A/ST-B/ST-C行為比較 59
4.4陡坡段軌橋互制行為數值模擬分析 60
4.4.1軌橋結構 60
4.4.2分析模型參數設定 61
4.4.3監測數據與數值模擬分析方法比對說明 65
4.4.4大梁伸縮縫相對位移量數值模擬分析 67
4.4.5道版與鋼軌相對位移 68
4.4.6鋼軌與鋼軌墊片相對位移數值模擬分析 70
4.4.7鋼軌軸力數值模擬分析 72
4.4.8鋼軌初始應力狀態推算 74
4.4.9鋼軌墊片破壞區間探討 76
4.4.10 SS-A/SS-B之行為比較 80
4.5曲線段軌橋互制行為數值模擬分析 81
4.5.1軌橋結構 81
4.5.2分析模型參數設定 82
4.5.3監測數據與數值模擬分析方法比對說明 88
4.5.4大梁伸縮縫相對位移量數值模擬分析 90
4.5.5道版與鋼軌相對位移 91
4.5.6鋼軌與鋼軌墊片相對位移數值模擬分析 93
4.5.7鋼軌軸力數值模擬分析 94
4.5.8鋼軌初始應力狀態推算 96
4.5.9鋼軌墊片破壞區間探討 98
4.5.10 CS-A/CS-B之行為比較 102
第五章橋梁與軌道系統動力模擬分析 103
5.1前言 103
5.2鋼軌墊片受外力荷載影響分析 103
5.2.1參數設定 103
5.2.2分析結果 107
5.3基鈑墊片受外力荷載影響分析 111
5.3.1參數設定 111
5.3.2分析結果 112
5.4軌橋系統溫差行為變化模擬 114
第六章結論與建議 120
6.1結論 120
6.2建議 122
參考文獻 124
附錄A SGS墊片拉伸試驗曲線及報告書 127
附錄B 螺栓鎖固扭矩反算 134

參考文獻

[1] 國立中央大學橋梁與軌道工程研究中心，臺灣桃園國際機場聯外捷運系統建設計畫「軌道及橋梁監測作業」委託技術服務案第一季監測季報告(2017)，交通部高速鐵路工程局。
[2] 陳恩加，「鋼軌扣件組破壞模擬分析」，碩士論文，國立臺北科技大學，台北(2019)。
[3] 黃民仁，張欽亮，新世紀鐵路工程學基礎篇，文笙書局，臺北(2013)。
[4] 黃民仁，新世紀鐵路工程學，文笙書局，臺北(2005)。
[5] 交通部，1067公厘軌距軌道橋隧檢查養護規範，臺北(2014)。
[6] Union Internationale des Chemins de fer. UIC Code 774–3R. Track/bridge interaction. Recommendations for calculations. Paris: International Union of Railways(2001).
[7] DIN. DIN-fachbericht 101. Einwirkungen auf Brücken. Berlin(2003).
[8] Chinese national standards. TB10015-2012. Code for design of railway continuous welded rail. Beijing(2012).
[9] Luo, Jun., Zeng, Zhiping., “A novel algorithm for longitudinal track-bridge interactions considering loading history and using a verified mechanical model of fasteners”, Engineering Structures, Vol 183, pp.52-68(2019).
[10] Ramosa, Ó.R., Schanackb, F., Ortega Carrerasc, G., Vena Retuertoc de , J., “Bridge length limits due to track-structure interaction in continuous girder prestressed concrete bridges”, Engineering Structures, Vol 196(2019).
[11] Yun, Kyung-Min., Bae, Hyun-Ung., Jiho Moon, Kim, Jung-Joong., Park, Jong-Chan., Lim, Nam-Hyoung., “Quantification of ballasted track-bridge interaction behavior due to the temperature variation through field measurements”, NDT and E International, Vol 103, pp.84–97(2019).
[12] Sung, Deokyong.,and Chang, Seongkyu., “Nonlinear behavior of rail fastening system on slab track at railway bridge ends: FEA and experimental study”, Engineering Structures, Vol 195, pp.84–95(2019).
[13] Zhang, J., Wu, D.J., Li, Q., “Loading-history-based track–bridge interaction analysis with experimental fastener resistance”, Engineering Structures ,Vol 83, pp.62–73(2015).
[14] 宋照清，「多跨簡支梁橋上無縫線路縱向力研究」，碩士論文，北京交通大學，中國(2011)。
[15] Ruge, P., and Birk, C., “Longitudinal forces in continuously welded rails on bridgedecks due to nonlinear track–bridge interaction”, Computers and Structures, Vol.85, pp.458-475(2007).
[16] Xu, Qing-yuan., Zhou, Xiao-lin., Zeng, Zhi-ping., and Yang, Xiao-li., “Mechanics model of additional longitudinal force transmission between bridges and continuously welded rails with small resistance fasteners” Journal of Central South University of Technology,Vol. 11, pp.336–339(2004).
[17] 王維銘，「螺栓/螺絲/螺帽扣件之旋緊鎖固」，螺絲世界雙月刊，第98-102頁(2020)。
[18] 許維倫，陳則銘，許書銘，「鐵路橋橋軌互制案例分析及規範探討」，中興工程，第118期，第49-55頁(2013)。
[19] Xu, Lei., and Zhai, Wanming., “A three-dimensional model for train-track-bridge dynamic interactions with hypothesis of wheel-rail rigid contact”, Mechanical Systems and Signal Processing , Vol. 132, pp.471-489(2019).
[20] Rakesh Kumar, and Akhil Upadhyay, “Effect of temperature gradient on track-bridge interaction”, Interaction and Multiscale Mechanics, Vol. 5, No. 1, pp.1-12(2012).
[21] Kjell, G., and Johnson, E., “Measuring axial forces in rail by forced vibrations:experiences from a full-scale laboratory experiment” SP Technical Research Institute of Sweden, Borås, Sweden, Vol. 223, pp.241-254(2009).
[22] Fedorova, M., and Sivaselvan, M.V., “An algorithm for dynamic vehicle-track-structure interaction analysis for high-speed trains”, Eng. Struct. Vol. 148, pp.857–877(2017).
[23] Lou, P., Yu, Z.W., Au, F.T.K., “Rail-bridge coupling element of unequal lengths for analysing train-track-bridge interaction systems”, Appl. Math. Model. 36, pp.1395–1414(2012).
[24] Rajamani, R., “Long welded rails on girder bridges”, P-Way Bulletin(1987).
[25] Ferdinand P.Beer, E.Russeell Johnston.Jr, David F.Mazurek, “Vector Mechanics for Engineers: Statics”,Eleventh Edition in SI Units, pp. 430-451(2016).
[26] LI, Q.T., LUO,Y., LIU, Y., “ Estimating clamping force of rail fastener system by experimental and numerical methods ”, Institute of Rail Transit, Tongji University, No. 4800 Cao’an Road, Shanghai, China(2018).
[27] Kaewunruen, S., Remennikov, AM. “Field trials for dynamic characteristics of railway track and its components using impact excitation technique”, NDT E International, Vol. 40, Issue 7, pp. 510-519(2007).
[28] Gallagher, GP., Leiper, Q., Williamson, R., Clark, MR., Forde, MC. “The application of time domain ground penetrating radar to evaluate railway track ballast”, NDT E International, Vol. 32, Issue 8, pp. 463-468(1999).
[29] RYJAČEK, P., VOKAČ, M. “Long-term monitoring of steel railway bridge interaction with continuous welded rail”, J Constr Steel Res, Vol. 99, pp. 176-186(2014).
[30] Strauss, A., Karimi, S., Kopf, F., Capraru, C., Bergmeister, K. “Monitoring‐based performance assessment of rail‐bridge interaction based on structural reliability”, Structural Concrete , Vol. 16, Issue 3, pp. 342-355(2015).
[31] Papp, H., Liegner, N., “Investigation of internal forces in the rail due to the interaction of CWR tracks and steel railway bridges with ballasted track superstructure”, Pollack Period , Vol. 11, Issue 2, pp. 65–74(2016).
[32] 尚紅霞，「地鐵扣件系統靜動力分析研究」，碩士論文，西南交通大學，中國(2011).
[33] 孫大新，高亮，劉衍峰，「橋上無碴軌道無縫道岔力學特性分析」，北京交通大學學報，第31卷第1期，第89-92頁(2007)。
[34] 張文城，蘇宗寶，彭仁忠，「桃園機場聯外捷運軌道系統工程施工探討」，中華技術，第94期，第56-75頁(2012)。
[35] 楊漢生，張正欣，「鐵路橋梁與無道碴軌道設計」，中華技術，第72期(2006)。
[36] 楊漢生、張正欣，「長銲鋼軌與鐵路橋梁」，中華技術，第64期(2004)。
[37] 陳韋凱，「嵌埋式軌道跨橋段有限元素分析」，碩士論文，國立成功大學，台南(2015)。
[38] 韓宗豪，「軌溫之無限監測與預測模型」，碩士論文，國立成功大學，台南(2015)。
[39] 施柔依，「向量式有限元運用於車軌橋互制數值模擬分析」，碩士論文，國立中央大學，桃園(2010)。
[40] 邱宇彰，張正欣，歐文爵，「彈性 PC 軌枕防振直結軌道與橋上長軌設計案例」，中華技術，第67期(2005)。

指導教授

王仲宇(Chung-Yue Wang)

審核日期

2020-8-18

推文