顆粒混合指標性能之研究

以作者查詢圖書館館藏

、以作者查詢臺灣博碩士

、以作者查詢全國書目

、勘誤回報

、線上人數：20

、訪客IP：3.131.37.82

姓名

宋岳樓(Yueh-Lou Sung) 查詢紙本館藏

畢業系所

機械工程學系

論文名稱

顆粒混合指標性能之研究
(The study of the performance of Mixing indices.)

相關論文

★ 筆記型電腦改良型自然對流散熱設計	★ 移動式顆粒床過濾器濾餅流場與過濾性能之研究
★ IP67防水平板電腦設計研究	★ 汽車多媒體導航裝置散熱最佳化研究
★ 流動式顆粒床過濾器三維流場觀察及能性能測試	★ 流動式顆粒床過濾器冷性能測試
★ 流動式顆粒床過濾器過濾機制研究	★ 二維流動式顆粒床過濾器內部配置設計研究
★ 循環式顆粒床過濾器過濾性能研究	★ 流動式顆粒床過濾器之流場型態設計與研究
★ 流動式顆粒床過濾器之流動校正單元設計與分析研究	★ 流動式顆粒床過濾器之雙葉片型流動校正單元設計與冷性能過濾機制研究
★ 稻稈固態衍生燃料成型性分析之研究	★ 流動式顆粒床過濾器之不對稱葉片設計與冷性能過濾機制研究
★ 流動式顆粒床過濾器之滾筒式粉塵分離系統與冷性能過濾及破碎效應研究	★ 稻稈固態衍生燃料加入添加物成型性分析之研究

檔案

[Endnote RIS 格式]

[Bibtex 格式]

[相關文章]

[文章引用]

[完整記錄]

[館藏目錄]

[檢視]

[下載]

本電子論文使用權限為同意立即開放。
已達開放權限電子全文僅授權使用者為學術研究之目的，進行個人非營利性質之檢索、閱讀、列印。
請遵守中華民國著作權法之相關規定，切勿任意重製、散佈、改作、轉貼、播送，以免觸法。

摘要(中)

本論文研究顆粒體在不同的預先排列配置下，以不同的混合指標，對系統內顆粒體混合程度的分析，以及對於目前針對混合研究中常見的Lacey Mixing Index，提出另一新混合指標加以比較分析其優缺點。
研究結果顯示，在完全分離的狀態下，平均高度指標會較其他混合指標來的較為準確。而在混合過程中，平均高度混合指標，會因為系統內顆粒體分布的關係，對其所計算出之混合度發生影響。而Lacey Mixing Index 在某些特殊顆粒排列下會計算出較高的混合值，同時選取cell的大小對其後計算出的系統混合值亦有相當大之影響。
在本文中，沒有混合指標可準確的反應當下系統內顆粒體所處的真實混合度，混合指標間的優劣差異是在於能提供一相對穩定的混合趨勢指示。

摘要(英)

This study represents the degree of mixing with different mixing index under the presetting particle system, and develops a new mixing index to compare with Lacey mixing index which is the most be used in granular mixing study and analyzed the performance of these two indices.
According to the results, the AVG. mixing index will indicate the best value in fully segregation and mixing state of system, but in the processing of mixing, the AVG. mixing value will be influenced by the distribution of particles in the system. And Lacey mixing will give higher mixing value while some special particle pattern, and the choice of cell size is a very important factor about the result of mixing value.
In this study no mixing indices can represent the degree of mixing of system precisely. To evaluate the degree of mixing of system depends on the feature of mixer or mixing mechanism, and the mixing index can give a relative accuracy and stable mixing values.

關鍵字(中)

★ 混合指標
★ 混合
★ Lacey mixing index

關鍵字(英)

★ Lacey Mixing index
★ Mix
★ Mixing index

論文目次

摘要 i
Abstract ii
第一章簡介 1
1.1粒子流簡介 1
1.1.1粒子流介紹 1
1.1.2粒子流與一般流體之異同 1
1.2 顆粒混合之研究發展 3
1.3 混合指標的介紹 4
1.4 研究動機與方向 5
2.1常用混合指標的背景 7
2.1.1平均高度混合指標 7
2.1.2 Lacey Mixing Index 8
2.1.3Kramer Mixing Index 10
2.1.4 Lacey, Weidendam and Bonilla Mixing 10
2.2研究原理與方法 11
第三章結果與討論 15
3.1不同預先配置與混合指標 15
3.1.1不同的起始分離系統與混合指標 15
3.1.2 Cell大小對Lacey Mixing Index的影響 17
3.1.4 特殊排列配置與混合指標 18
3.2配位數混合指標與Lacey混合指標 20
第四章結論 22
參考文獻 24

參考文獻

[1] Campbell, C. S. and Brennen, C.E. , 1895, “Chut flow of granular material: some computer simulations. ”J. Appl. Mech. Vol. 52, pp. 72-178.
[2] Faraday, M. , 1831, “On a peculiar Class of Acoustical Figures and on Certain Forms Assumed by Groups of Particles upon Vibrating Elastic Surfaces”. Philsosphical Transactions of the Royal Society of London, Vol. 121, pp. 299-340
[3] Reynolds, O. , 1885, “On the Dilatancy of Media Composed od Rigid Particle in Contact, with Experiment Illustration. ” Phil. Mag., Vol. 20, pp. 469-481.
[4] Hsiau, S. S. and Hunt, M. L. , 1993, “Kinetic Theory Analysis of Flow-induce Particle Diffusion and Thermal Conduction in Granular.
[5] Lacey P. M. C. , 1953, “Developments in the theory of particle mixing.”, J. Appl. Chem., Vol. 4 Issue 5, pp. 257 -268.
[6] Chandratilleke G. R., Yu A. B. , Stewart R.L., Bridgwater J. , 2009, “Effects of blade rake angle and gap on particle mixing in a cylindrical mixer.”, Powder Technol. Vol. 193 pp. 303–311 .
[7] Lu L. S. , Hsiau S. S. ,2008, “Mixing in a vibrated granular bed: Diffusive and convective effects. ” , Powder Technol. Vol. 184, pp.31-43.
[8] Troy S., Albert A., Maher M. and Fernando J. M., 1999, “Chaotic granular mixing.”, American Institute of Phy. , Vol. 9. pp. 611-620
[9] Weidenbaum, S. S., 1958, “Solids Mixing. ”Advances in Chemical Eng. II, pp. 211-321.
[10] Lacey, P. M. C. , 1943, “The Mixing of Solid Particles.” Tram. Inst. Chern. Engrs. , 21, pp. 53-59.
[11] Gayle, J. B., Lacey, 0. L., and Gary, J. H., 1958, “Mixing of Solids-x-quare as a Criterion,” Ind. Eng. Chem., pp. 1279-1282.
[12] Leggatt C. W., 1951 “Method of Making the Homogeneity Test,” 1951. Assoc. Official Seed Analysis News Letter. Vol. 25
[13] Venables, H. J. , Wells, J. I., 2001, “Powder mixing,” Drug Development and Industrial Pharm. , Vol. 27, No. 7, pp. 599-612.
[14] Rhodes, M., 1998, Introduction to Particle Technology. (John Wiley & Sons, London).
[15] Cooke, W. , Warr, S. , Huntley, J. M. and Ball, R. C., 1996, “Particle size segregation in a two-dimentional bed undergoing vertical vibration.” Phys. Rev. E. , Vol. 53, pp.2812-2822 .
[16] Knight, J. B., Ehrichs, E. E., Kuperman, V. Y., Flint, Jaeger, H. M and Nagel, S. R. ,1996, “An experimental study of granular convection.”Phys. Rev. E., Vol. 54, pp. 5726-5738 .
[17] Hsiau, S. S. and Tai, C. H. , 2004, “Dynanic Behavior of Powders in a Vibrating Bed.”Powder Technol. , Vol. 139 No. 3, pp.221-232
[18] Fan L. T. , Chen S. J. , And Watson C. A., 1970, “Solid Mixing. ” Industrial and Eng. Chem,.Vol. 62, No.7, pp.53-69.
[19] Alhwaige A. A., S. M. Tasirin, A. M. Sowedan, W. R. W. Daud, 2008, “Study The Homogeneity of Mixing a Binary Polyethylene Granular Mixture in Fluidised Bed Mixer. ”WCECS.
[20] L.S.Lu and S.S.Hsiau., 2006 “Study of granular mixing in vibrated beds and
sheared flows by DEM simulations”.,中央大學博士論文
[21] Shah R. , Manickam S.S. , Tomei J. , Bergman T.L., Chaudhuri B. 2009, “Mixing Study in a Multi-dimentional Motion Mixer. ”, Powder and Grains, pp.683-686.
[22] Kramer H . A., 1968 “Effect of Grain Velocity and Flow Rate Upon the Performance of a Diverter Type Sampler,” U.S. Dept. Agr. , ARS 51-25 .
[23] Weidenbaum, S. S., and Bonilla, C. F. , 1953, “ A Fundamental Study of the Mixing of Particulate Solids,” Ph.D. Thesis, Columbia Univ.
[24] Poux M, Fayolle P, Bertrand J, Bridoux D, Bousquet J, 1991, “Powder mixing
some practical rules applied to agitated systems. ”Powder-Technol.
.Vol. 68, issue3, pp. 213-234.
[25] Poole K. R. M. A., Taylor R. F. M.Sc., Wall G. P. , 1964, “Mixing Powders to fine-scale. homogeneity: studies of batch mixing. ”Chem. Eng. Research and Design.Vol. 42a, No.7, pp. 305-315.
[26] Deveswaran R. , Bharath S. , Basavaraj B. V. , Abraham S. , Furtado S. and Madhavan V. , 2009, “Concepts and Techniques of Pharmaceutical Powder Mixing Process: A Current Update. ”Research J. Pharm. and Tech2(2)., pp.245-249.
[27] Henrique, C., Batrouni, G. and Bideau, D., 2000, “Diffusion as a Mixing Mechanism in Granular Materials.” Phys. Rev. E., Vol. 63, No.1, pp. 1304-1311.
[28] Sahoo A. and Roy G.K. , 2005 “Mixing characteristic of homogeneous binary mixture of regular particles in a gas–solid fluidized bed.”Powder Technol. Vol. 159, Issue 3, pp. 150-154.
[29] S.S.Hsiau and H.Y.Yu., 1998 “Segregation phenomena in a shacker.”, Powder
Technol. , Volume 53, Number 6, June 1998 , pp. 35-35

指導教授

蕭述三(Shu-San Hsiau)

審核日期

2012-7-19

推文