博碩士論文 92333020 詳細資訊




以作者查詢圖書館館藏 以作者查詢臺灣博碩士 以作者查詢全國書目 勘誤回報 、線上人數:8 、訪客IP:35.172.111.71
姓名 游本良(Pen-Liang Yu)  查詢紙本館藏   畢業系所 機械工程學系在職專班
論文名稱 冷卻水溫度與冰水溫度對離心式冰水主機性能影響之實驗分析
(The experimental analysis of the effect of cooling water and chilled water temperature on centrifugal chiller performance)
相關論文
★ 不同結構與幾何形狀對熱管性能之影響★ 油冷卻器熱傳與壓降性能實驗分析
★ 水對冷媒R22在板式熱交換器內之性能測試分析★ 水對水在不同板片型式之板式熱交換器性能測試分析與比較
★ 油冷卻器性能測試分析與比較★ 空調機用水簾式暨光觸媒空氣清淨機 研製及測試
★ 水對空氣在板式熱交換器之性能測試分析★ 板片入出口及入出口管路壓降估計對板式熱交換器壓降性能影響分析
★ 微熱交換器之設計與性能測試★ 板式熱交換器之入出口壓降實驗分析
★ 液體冷卻系統中之微熱交換器性能分析與改良★ 直接模擬蒙地卡羅法於高低速流場之模擬
★ 液體微熱交換器之熱傳增強研究★ 冷媒R22在板式熱交換器內之凝結熱傳及壓降性能實驗分析
★ 不同參數對燒結式熱管性能之影響研究★ 使用不同擋板集管之多通道熱交換器流動分佈觀察
檔案 [Endnote RIS 格式]    [Bibtex 格式]    [相關文章]   [文章引用]   [完整記錄]   [館藏目錄]   至系統瀏覽論文 ( 永不開放)
摘要(中) 台灣地處於亞熱帶區域,夏季氣候高溫高濕,需要大量的空調設施,尤其是工業生產所需的無塵室,需要大量的冰水做為溫度與濕度控制之用,冰水主機為冰水系統的核心機件,其效率的高低對能源的消耗有極大的影響。
本文討論冰水主機水側溫度變化對冰水主機效率的影響,使用田口實驗計畫法的直交表做實驗,並以TFT-LCD廠實際的運轉數據為分析依據,將冰水主機冷卻水進口溫度與COP的線性迴歸關係式找出,可以很明確的顯示COP值隨著冷卻水進口溫度降低而升高;關於冰水溫度的影響,想要提升COP值,主要在於必須增加冰水進口與出口的溫度差ΔT,若是只有提高冰水主機的冰水出口溫度而無法同時增加ΔT,則未必能夠有效的提高COP值。
摘要(英) Taiwan is located in the subtropical area with hot and humid climate in the summer. It requires a large number of air conditioning facilities. The chilled water is used to control the temperature and humidity in the industry, especially for the clean room to maintain the constant temperature and humidity. The chiller is the heart of the chilled water system, and its efficiency has a great influence on consumption of the energy.
This research experimentally studies the performance of the chiller in different water temperature. The Taguchi method is used to analysis the results of the experiments. From the operation data of the TFT-LCD factory, a linear regression of the chiller’s COP versus its condenser inlet water temperature can be found. The result shows that the COP of the chiller will increase with decreasing condenser inlet water temperature. Because the variation of chilled water temperature tested is too small, the effect of the chilled water to the COP is not significant.
關鍵字(中) ★ 冰水主機
★ 冰水系統
關鍵字(英) ★ Chiller
★ Chilled water system
★ COP
論文目次 目錄
摘要 i
Abstract ii
誌謝 iii
目錄 iv
表目錄 vi
圖目錄 viii
符號說明 x
第一章 前言 1
1.1 研究背景 1
1.2 研究目的 2
第二章 文獻回顧 7
2.1 冰水主機的理論模型及系統模擬 7
2.2 冰水主機的測試 8
2.3 冰水主機的性能 9
2.4 節能與環保議題 10
第三章 實驗方法 18
3.1 實驗系統 18
3.2 實驗量測設備 21
3.3 實驗數據計算 22
3.4 直交表 22
第四章 實驗結果與討論 34
4.1 冰機的效率表示法 34
4.2 直交表實驗 36
4.3 冷卻水溫度的影響 39
4.4 冰水溫度的影響 41
第五章 結論 69
參考文獻 70
附錄
A.空調系統冰水主機能源效率標準 73
B.實驗誤差分析 74
C.蒸氣壓縮循環的熱力分析 76
參考文獻 參考文獻
1.經濟部能源局, “中華民國93年能源統計手冊”, 民國94年5月
2.友達光電龍潭廠廠務部, “LT用電量統計”, 民國94年
3.Browne, M.W., and Bansal, P.K., 1998, “Challenges in modeling vapor-compression liquid chillers”, ASHRAE Transaction, pp. 474-486.
4.Yasuda, H., Touber, S. and Machielson, C.H.M., 1983, “Simulation model of a vapor compression refrigeration system”, ASHARE Transaction, Vol.89, part2A, pp. 408-425.
5.Browne, M.W., and Bansal, P.K., 2002, “Transient simulation of vapour-compression packaged liquid chillers”, International Journal of Refrigeration 25, pp. 597–610.
6.Le, C.V., Bansal, P.K., and Tedford, J.D., 2004, “Three-zone system simulation model of a multiple-chiller plant”, Applied Thermal Engineering 24, pp.1995-2015.
7.ARI Standard 550/590, 2003, “Performance rating of water-chilling packages using the vapor compression cycle”, Air-conditioning & Refrigeration Institute.
8.經濟部標準檢驗局,”中國國家標準CNS12575容積式冰水機組”,民國78年8月12日公告
9.經濟部標準檢驗局,”中國國家標準CNS12812離心式冰水機組”,民國79年12月26日公告
10.Brandemuehl, M.J., Phelan, J., and Krarti, M., 1997, “In-Situ Performance Testing of Chillers for Energy Analysis”, ASHRAE Transaction, V. 103, Pt. 1.
11.Browne, M.W., and Bansal, P.K., 1998, “Steady-state model of centrifugal liquid chillers”, International Journal of Refriggeration, Vol. 21, No. 5, pp. 343-358.
12.Fu, L., Ding, G., Su, Z., and Zhao, G., 2002, “Steady-state simulation of screw liquid chillers”, Applied Thermal Engineering 22, pp. 1731-1748.
13.Gordon, J.M., Ng, K.C., Chua, H.T., and Lim, C.K., 2000, “How varying condenser coolant flow rate affects chiller performance: thermodynamic modeling and experimental confirmation”, Applied Thermal Engineering 20, pp. 1149-1159.
14.Chang, Y.C., 2004, “A novel energy conservation method— optimal chiller loading”, Electric Power Systems Research 69, pp. 221-226.
15.Yu, F.W., and Chan, K.T., 2005, “Experimental determination of the energy efficiency of an air-cooled chiller under part load conditions”, Energy 30, pp.1747-1758.
16.Lenarduzzi, F.J., and Yap, S.S., 1998, “Measuring the Performance of a Variable-Speed Drive Retrofit on a Fixed-Speed Centrifugal Chiller”, ASHRAE Transaction, V. 104, Pt. 2.
17.Grace, I.N., and Tassou, S.A., 2001, “Simulation of the performance of alternative refrigerants in liquid chillers”, Proceedings of the Institution of Mechanical Engineers, Vol 215 Part A, pp. 429-441.
18.Calm, J.M., 2002, “Options and outlook for chiller refrigerants”, International Journal of Refrigeration 25, pp. 705-715.
19.陳耀茂譯, 2004, “實驗計劃法入門”, 財團法人中衛發展中心
20.SIMENS I&S IT PS 12 P1, 2002, “MIS-Light User Manual”, V2.6, Release 10.
21.Cengel, Y.A., and Boles, M.J., 1989, “Thermodynamics:An Engineering Approach”, International Edition, McGraw-Hill,Inc.
22.Kays, W. M., and London, A. L., 1984, “Compact Heat Exchangers”, Third Edition, McGraw-Hill, Inc.
23.Stoecker, W. F., 1989, “Design of Thermal Systems”, Third Edition, McGraw-Hill, Inc.
指導教授 楊建裕(Chien-Yuh Yang) 審核日期 2006-7-20
推文 facebook   plurk   twitter   funp   google   live   udn   HD   myshare   reddit   netvibes   friend   youpush   delicious   baidu   
網路書籤 Google bookmarks   del.icio.us   hemidemi   myshare   

若有論文相關問題,請聯絡國立中央大學圖書館推廣服務組 TEL:(03)422-7151轉57407,或E-mail聯絡  - 隱私權政策聲明