不同表面粗糙度的大顆粒在垂直式振動床中動態行為之研究

以作者查詢圖書館館藏

、以作者查詢臺灣博碩士

、以作者查詢全國書目

、勘誤回報

、線上人數：18

、訪客IP：18.117.111.1

姓名

吳啟碩(Chi-shou Wu) 查詢紙本館藏

畢業系所

能源工程研究所

論文名稱

不同表面粗糙度的大顆粒在垂直式振動床中動態行為之研究
(The dynamics of intruders differing in surface roughness in a vertical vibrated granular bed)

相關論文

★ 二維儲槽濾材顆粒流場之研究	★ 粗細顆粒混合之流動性質分析
★ MOCVD腔體熱流場與新式進氣檔板之設計模擬分析研究	★ 稻殼於流體化床進行快速裂解產製生質燃油之研究
★ 利用CFD 模擬催化生質能在快速熱裂解中碳沉積對於催化劑去活化反應影響	★ 反向氣流對微小粉末於儲槽排放行為影響之研究
★ 積層製造自動化粉末回收系統-系統設計及其混合器之優化	★ 雙床氣化爐冷模型中CFB入口速度、BFB床高和顆粒尺寸對矽砂之壓力分佈和質量流率的影響
★ 以實驗方式探討崩塌流場對可侵蝕底床侵蝕與堆積現象之影響	★ 移動式顆粒床過濾器應用於去除PM2.5之研究
★ 超臨界顆粒流場中雙圓柱阻礙物震波交互影響之研究	★ 添加微量液體對振動床中顆粒體分離現象的影響
★ 二維剪力槽中顆粒體群聚現象之研究探討	★ 直渠道顆粒流之顆粒密度分離效應
★ 粉粒體於儲槽排放行為及氣泡現象之研究	★ 初始體積占有率影響顆粒崩塌行為之研究

檔案

[Endnote RIS 格式]

[Bibtex 格式]

[相關文章]

[文章引用]

[完整記錄]

[館藏目錄]

[檢視]

[下載]

本電子論文使用權限為同意立即開放。
已達開放權限電子全文僅授權使用者為學術研究之目的，進行個人非營利性質之檢索、閱讀、列印。
請遵守中華民國著作權法之相關規定，切勿任意重製、散佈、改作、轉貼、播送，以免觸法。

摘要(中)

本研究探討在類二維的振動床系統中，不同表面粗糙度的大顆粒(或稱Intruder)在顆粒床中的巴西豆現象。所謂的巴西豆現象是指顆粒因為大小的不同，粒徑較大的顆粒會隨著時間上升至自由表面，而較小的顆粒會沉在容器底部。本研究以高速攝影機擷取大顆粒在顆粒床裡的動態行為，並藉由改變不同的振動條件以及顆粒床填充高度，觀察這些條件對不同表面粗糙度的大顆粒上升行為的影響。
本研究的實驗結果顯示，大顆粒的上升時間隨著無因次振動加速度增加而增長，隨著振動頻率增加而減少，上升速度隨著填充高度增加而減少。而且摩擦係數比較大的大顆粒，因為上升過程中，摩擦力造成的能量消散較大，從容器底部上升到自由表面的時間會比較長，摩擦係數較小的大顆粒，則因為摩擦力對它上升過程中的影響較小，所以上升地較快。而且不同摩擦係數大顆粒的上升時間，在較小無因次振動加速度、較大振動頻率以及較大的填充高度下，差異較為明顯。

摘要(英)

This study investigates experimentally the Brazil-nut effect in a quasi-2D vertical vibrated granular bed, the only difference lying in the surface roughness of the larger disks (or called intruders). The so-called “Brazil nut problem” means the larger particle rises to the top of the container and the smaller particles move to the bottom. The dynamics of the larger disk is recorded by using a high speed camera. The effects of vibration conditions and filling height of the granular bed on the dynamics of intruder are investigated in the study.
The results show that the rising velocity decreases with increasing granular bed filling height. It also shows that the rising time becomes faster with the larger dimensionless vibration acceleration and smaller vibration frequency is applied in the granular system. However, the rise time of the rough disks is smaller than the smooth one because of the larger energy dissipation of the rough disks. Additionally, the difference in the rising time between the rough and smooth intruders is more significant with the smaller dimensionless vibration acceleration, higher vibration frequency and higher granular bed filling height.

關鍵字(中)

★ 顆粒流
★ 振動床
★ 表面粗糙度
★ 巴西豆效應

關鍵字(英)

★ Granular flow
★ Vibrated bed
★ Brazil-nut effect
★ Surface roughness

論文目次

摘要 i
Abstract ii
目錄 iii
附圖目錄 v
附表目錄 viii
符號說明 ix
第一章簡介 1
1.1 粒子流簡介 1
1.2 顆粒材料的運動現象 2
1.3 顆粒材料的分離現象 4
1.3.1 巴西豆現象與逆巴西豆現象 4
1.3.2 單一大顆粒(intruder)置於顆粒床內的分離現象 8
1.3.3 摩擦係數對顆粒材料分離的影響 11
1.4 研究動機 13
第二章實驗設備與方法 14
2.1 實驗設備 14
2.2 實驗參數說明 17
2.3 實驗流程 18
2.4 影像分析程式 18
2.5 誤差分析 20
第三章結果與討論 21
3.1 無因次振動加速度對不同表面粗糙度的大顆粒其動態行為的影響 21
3.2 振動頻率對不同表面粗糙度的大顆粒其動態行為的影響 26
3.3 改變顆粒床填充高度對不同表面粗糙度的大顆粒動態行為的影響 30
3.4 大顆粒的摩擦係數對於其上升行為的影響 32
第四章結論 34
參考文獻 35

參考文獻

Aoki, K. M., Akiyama T., Maki Y. and Watanabe T., 1996, “Convective roll patterns in vertically vibrated beds of granules,” Physical Review E, Vol. 54, pp. 874-883.
Bates, L., 1997, User Guide to Segregation
Bose, M. and Rhodes, M., 2007, “Dynamics of an intruder in a shaken granular bed,” Powder Technology, Vol. 179, pp. 25-30.
Breu, A. P. J., Ensner, H. M., Kruelle, C. A. and Rehberg I., 2003, “Reversing the Brazil-nut effect: Competition between percolation and condensation,” Physical Review Letters, Vol. 90, 014302.
Brito, R. and Soto, R., 2009, “Competition of Brazil nut effect, buoyancy, and inelasticity induced segregation in a granular mixture,” European Physical Journal Special Topics, Vol. 179, pp. 207-219.
Carson, J. W. and Wilms, H., 2006, “Development of an international standard for shear testing,” Powder Technology, Vol. 167, pp. 1-9.
Ciamarra, M. P., De Vizia, M. D., Fierro, A., Tarzia, M., Coniglio, A. and Nicodemi, M., 2006, “Granular species segregation under vertical tapping: Effects of size, density, friction, and shaking amplitude,” Physical Review Letters, Vol. 96, 058001.
Clement, C. P., Pacheco-Martinez, H. A., Swift, M. R. and King, P. J., 2010, “The water-enhanced Brazil nut effect,” Europhysics Letters, Vol. 91, 54001.
Cooke, W., Warr, S., Huntley, J. M. and Ball, R. C., 1996, “Particle size segregation in a two-dimensional bed undergoing vertical vibration,” Physical Review E, Vol. 53, pp. 2812-2822.
Duran, J., Mazozi, T., Clement, E. and Rajchenbach, J., 1994, “Size segregation in a two-dimensional sandpile: Convection and arching effects,” Physical Review E, Vol. 50, pp. 5138–5141.
Duran, J., Rajchenbach, J. and Clement, E., 1993, “Arching effect model for particle size segregation,” Physical Review Letters, Vol. 70, pp. 2431-2434.
Dziugys, A. and Navakas, R., 2009, “The role of friction in mixing and segregation of granular material,”Granular Matter, Vol. 11, pp. 403-416.
Elperin, T. and Golshtein, E., 1997, “Effects of convection and friction on size segregation in vibrated granular beds,” Physica A, Vol. 247, pp. 67-78.
Gotzendorfer, A., Tai, C. H., Kruelle, C. A., Rehberg, I. and Hsiau S. S., 2006, “Fluidization of a vertically vibrated two-dimensional hard sphere packing: A granular meltdown,” Physical Review E, Vol. 74, 011304.
Hong, D. C., Quinn, P. V. and Luding, S., 2001, “Reverse Brazil nut problem: Competition between percolation and condensation,” Physical Review Letters, Vol. 86, pp. 3423-3426.
Hsiau, S. S., Lu, L. S., Chen, J. C. and Yan, W. L., 2005, “Particle mixing in a sheared granular flow,” International Journal of Multiphase Flow, Vol. 31, pp.793-808.
Hsiau, S. S. and Pan, S. J., 1998, “Motion state transitions in a vibrated granular bed,” Powder Technology, Vol. 96, pp.219-226.
Hsiau, S. S., Wang, P. C. and Tai, C. H., 2002, “Convection cells and segregation in a vibrated granular bed,” AIChE Journal, Vol. 48, pp.1430-1438.
Hsiau, S. S. and Yu, H. Y., 1997, “Segregation phenomena in a shaker,” Powder Technology, Vol. 93, pp.83-88.
Huerta, D. A. and Ruiz-Suarez, J. C., 2004, “Vibration-induced granular segregation: A phenomenon driven by three mechanisms,” Physical Review Letters, Vol. 96, pp.219-226.
Knight, J. B., Jaeger, H. M. and Nagel, S. R., 1993, “Vibration-induced size separation in granular media: The convection connection,” Physical Review Letters, Vol. 92, 114301.
Kondic, L., Hartley, R. R., Tennakoon, S. G. K., Painter, B. and Behringer R. P., 2003, “Segregation by friction,” Europhysics Letters, Vol. 61, pp. 742-748.
Lai, P. Y., Jia, L. C. and Chan, C. K., 1997, “Friction Induced Segregation of a Granular Binary Mixture in a Rotating Drum,” Physical Review Letters, Vol. 79, pp. 4994-4997.
Liao, C. C., Hsiau, S. S., Tsai, T. H. and Tai, C. H., 2010, “Segregation to mixing in wet granular matter under vibration,”Chemical Engineering Science, Vol. 65, pp. 1109-1116.
Liffman, K., Muniandy, K., Rhodes, M., Gutteridge, D. and Metcalfe, G., 2001, “A segregation mechanism in a vertically shaken bed,” Granular Matter, Vol. 3, pp. 205-214.
Lu, L. S. and Hsiau, S. S., 2005, “Mixing in vibrated granular beds with the effect of electrostatic ford,” Powder Technology, Vol. 160, pp. 170-179.
Lu, L. S. and Hsiau, S. S., 2008, “DEM simulation of particle mixing in a sheared granular flow,” Particuology, Vol. 6, pp. 445-454.
Mobius, M. E., Cheng, X., Karczmar, G. S., Nagel, S. R. and Jaeger, H. M., 2004, “Intruders in the dust: Air-driven granular size separation,” Physical Review Letters, Vol. 93, 198001.
Nahmad-Molinari, Y., Canul-Chay, G. and Ruiz-Suarez, J. C., 2003, “Inertia in the Brazil nut problem,” Physical Review E, Vol. 68, 041301.
Plantard, G., Saadaoui, H., Snabre, P. and Pouligny, B., 2006, “Surface roughness driven segregation in a granular slurry under shear,” Europhysics Letters, Vol. 75, pp. 335-341.
Pohlman, N. A., Severson, B. L., Ottino, J. M. and Lueptow, R. M., 2006, “Surface roughness effects in granular matter: Influence on angle of repose and the absence of segregation,” Physical Review E, Vol. 73, 031304.
Rosato, A. D., Ketherine, J. S., Friedrich, P. and Robert, H. S., 1987, “Why the brazil nuts are on top: size segregation of particulate matter by shaking,” Physical Review Letters, Vol. 58, pp. 1038-1040.
Saez, A., Vivanco, F. and Melo, F., 2005, “Size segregation, convection, and arching effect,” Physical Review E, Vol. 72, 021307.
Sánchez1, I., Gutiérrez, G., Zuriguel, I. and Maza, D., 2010, “Sinking of light intruders in a shaken granular bed,” Physical Review E, Vol. 81, 062301.
Shinbrot, T. and Muzzio, F. J., 1998, “Reverse buoyancy in shaken granular beds,” Physical Review Letters, Vol. 81, pp.4365-4368.
Srebro, Y. and Levine, D., 2003, “Role of friction in compaction and segregation of granular materials,” Physical Review E, Vol. 68, 061301.
Tai, C. H. and Hsiau, S. S., 2004, “Dynamic behaviors of powders in a vibrating bed,” Powder Technology, Vol. 139, pp. 221-232.
Ulrich, S., Schroter, M. and Swinney H. L., 2007, “Influence of friction on granular segregation,” Physical Review E, Vol. 76, 042301.
Vanel, L., Rosato, A. D. and Dave R. N., 1997, “Rise-time regimes of a large sphere in vibrated bulk solids,” Physical Review Letters, Vol. 78, pp. 1255-1258.
Yan, X., Shi, Q., Hou, M., Lu, K. and Chan, C. K., 2003, “Effects of air on the segregation of particles in a shaken granular bed,” Physical Review Letters, Vol. 91, 014302.
Yang, S. C., 2006, “Density effect on mixing and segregation processes in a vibrated binary granular mixture,” Powder Technology, Vol. 164, pp. 65-74.

指導教授

蕭述三(Shu-san Hsiau)

審核日期

2011-7-19

推文