刻紋後之酸鹼洗潔淨製程對磁記錄媒體之異向性及磁記錄性質之影響研究

以作者查詢圖書館館藏

、以作者查詢臺灣博碩士

、以作者查詢全國書目

、勘誤回報

、線上人數：32

、訪客IP：3.136.19.203

姓名

潘俊豪(Chun-Hai Pan) 查詢紙本館藏

畢業系所

機械工程學系

論文名稱

刻紋後之酸鹼洗潔淨製程對磁記錄媒體之異向性及磁記錄性質之影響研究
(The effects of cleaning process to the magnetic recording media on OR and magnetic recording properties.)

相關論文

★ 非破壞性探討安定化熱處理對Al-7Mg鍛造合金微結構、機械與腐蝕性質之影響	★ 非破壞性探討安定化熱處理對Al-10Mg鍛造合金微結構、機械與腐蝕性質之影響
★ 冷加工與熱處理對AA7055鍛造型鋁合金微結構與機械性質的影響	★ 冷抽量對AA7055(Al-Zn-Mg-Cu)-T6態合金腐蝕性質和微結構之影響
★ 熱力微照射製作絕緣層矽晶材料之研究	★ 分流擠型和微量Sc對Al-5.6Mg-0.7Mn合金微結構及熱加工性之影響
★ 銀對於鎂鎳儲氫合金吸放氫及電化學性質之研究	★ 氧化物催化劑對亞共晶Mg-Ni合金之儲放氫特性研究
★ 熱處理對7050鋁合金應力腐蝕與含鈧鋁薄膜特性之影響研究	★ Ti-V-Cr與Mg-Co基BCC儲氫合金性質研究
★ 鋰-鋁基及鋰-氮基複合儲氫材料之製程開發及研究	★ 銅、鎂含量與熱處理對Al-14.5Si-Cu-Mg合金拉伸、熱穩定與磨耗性質之影響
★ 恆溫蒸發熔煉鑄造製程合成鎂基介金屬化合物及其氫化特性之研究	★ 無電鍍鎳多壁奈米碳管對Mg-23.5wt.%Ni共晶合金儲放氫特性之影響
★ 微量Sc對A356鑄造鋁合金機械性質之影響	★ 熱處理對車用鋁合金材料熱穩定性與表面性質之影響

檔案

[Endnote RIS 格式]

[Bibtex 格式]

[相關文章]

[文章引用]

[完整記錄]

[館藏目錄]

[檢視]

[下載]

本電子論文使用權限為同意立即開放。
已達開放權限電子全文僅授權使用者為學術研究之目的，進行個人非營利性質之檢索、閱讀、列印。
請遵守中華民國著作權法之相關規定，切勿任意重製、散佈、改作、轉貼、播送，以免觸法。

摘要(中)

形成異向性媒體的機制中，刻紋製程及後續形成Cr(200)/Co(11.0)磊晶系統是不可或缺的兩項條件。本論文針對刻紋後續之酸鹼洗潔淨過程中雙氧水的添加與否，研究刻紋形態及結晶結構所受的影響。實驗結果顯示雙氧水的添加會造成鎳磷層表面氧化差異及刻紋形態的改變，因而降低橫向磁記錄媒體的異向性。
隨著異向性的降低，伴隨而來的影響是磁記錄性質的表現不佳。由於雙氧水的添加，使得訊號強度(LF)、訊號半高寬(PW50)、頻譜訊號雜訊比(SpectralSNR)等性質表現不佳。其中又以訊號雜訊比差異最為明顯。藉由各種訊號雜訊之分析比較，進一步釐清造成訊號雜訊比表現不佳的因素中，又以抹除訊號後之雜訊表現(Ndc)差異最為明顯。

關鍵字(中)

★ 鎳磷
★ 異向性
★ 訊號雜訊比
★ 磁性薄膜
★ 硬碟片刻紋製程
★ 磁性材料
★ 磁記錄

關鍵字(英)

★ cleaning
★ texture
★ SNR
★ magnetic recording
★ orientation ratio
★ media noise
★ dc noise
★ signal
★ NiP

論文目次

摘要……………………………………………………………………….I
總目錄…………………………………………………………………II
圖目錄…………………………………………………………………V
表目錄…………………………………………………………………VII
第一章、前言…………………………………………………………1
第二章、基本原理與文獻回顧………………………………………4
2-1. 磁記錄原理…………………………………………………………4
2-1-1.磁頭介紹………………………………………………………..4
2-1-1-1感應式磁頭(inductive head)…………………………………4
2-1-1-2磁阻式磁頭(magneto-resistance head, MR head)…………..6
2-1-2.磁記錄媒體基本架構…………………………………………..6
2-1-3.磁矩轉換區域(magnetization transition)……………………..9
2-2. 磁記錄性能的優劣判定…………………………………………11
2-2-1.等寬度記錄位元……………………………………………13
2-2-2.訊號與雜訊……………………………………………………13
2-2-3.反磁化場效應…………………………………………………16
2-3. 磁記錄媒體之架構與磁記錄性能之關係………………………..18
2-3-1.鎳磷層之性質…………………………………………………18
2-3-2.異向性磁記錄媒體之性質-OR……………………………….18
2-3-3.磁性層平均晶粒尺寸…………………………………………19
2-4. 表面粗糙度之表示………………………………………………..20
2-4-1.中心線平均粗糙度 (Ra)………………………………………20
2-4-2.最大粗糙度 (Rmax)……………………………………………20
第三章、分析儀器介紹……………………………………………..22
3-1.樣品震盪磁性量測儀(Vibration sample magnetometer, VSM)...22
3-2.X光繞射儀(X-ray diffractometer, XRD)…………………………24
3-3.掃描試探針顯微鏡…………………………………………………25
3-3-1.原子力顯微鏡(Atomic force microscope, AFM)……………25
3-3-2.磁力顯微鏡(Magnetic force microscope, MFM)……………25
3-4.X光光電子譜儀(X-ray photoelectron spectrometer, XPS)……..26
3-5.讀寫分析儀(Read-write analyzer, RWA)…………………………26
第四章、實驗方法與步驟…………………………………………..28
4-1. 磁記錄媒體之準備………………………………………………..28
4-1-1.基板的準備及酸鹼洗條件……………………………………28
4-1-2.鍍膜之程序與條件……………………………………………30
4-2. 記錄媒體之性質分析……………………………………………..30
第五章、實驗結果與討論…………………………………………..33
5-1.酸鹼洗製程對OR (Orientation Ratio)的影響…………………...33
5-1-1.酸鹼洗製程差異………………………………………………34
5-1-2.鎳磷層表面氧化差異…………………………………………34
5-1-3.刻紋形態比較…………………………………………………36
5-1-4.結晶結構比較…………………………………………………39
5-1-5.記錄媒體異向性的比較………………………………………39
5-2.酸鹼洗製程對紀錄媒體磁紀錄性質的影響………………………41
5-2-1.訊號半高寬(PW50)、訊號雜訊比(SNR)…………………….41
5-2-2.不同線記錄密度下訊號與各種雜訊之分析…………………44
第六章、結論……………………………………………………….52
第七章、參考文獻…………………………………………………..53

參考文獻

1. Eric E. Fullerton, D. T. Margulies, M. E. Schabes, M. Carey, B. Gurney, A. Moser, M. Best, G. Zeltzer, K. Rubin, and H. Rosen, M. Doner, “Antiferromagnetically coupled magnetic media layers for thermally stable high-density recording,” Appl. Phys. Lett. Vol.77,3806 (2000).
2. E. N. Abarra, B. R. Acharya, A. Inomata, and I. Okamoto, “Synthetic Ferrimagnetic Media,” IEEE Trans .Magn., vol.37, No.4, pp. 1426-1431 , JULY (2001).
3. E. N. Abarra, A. Inomata, H. Sato, I. Okamoto, and Y.Mizoshita.”Longitudinal magnetic recording media with thermal stabilization layers,” Appl. Phys. Lett. Vol.77,2851 (2000).
4. Alexander Taratorin, Characterization of Magnetic Recording Systems, , Guzik Technical Enterprises,1996.
5. R. LAWRENCE COMSTOCK, “INTRODUCTION TO MAGNETISM AND MAGNETIC RECORDING,” (1999).
6. 楊聰仁”無電鍍鎳研究與應用現況”，工業材料，第106期，pp.118-124，十月，84年。
7. E. Teng and N. Ballard,”Anisotropy Induced Signal Waveform Modulation of DC Magnetron Sputtered Thin Film Disks,” IEEE Trans. Magn., Vol. 22, pp.579-581, September 1986.
8. S. Uchinami, F. Beppu, s. Ito, N. Tokubuchi, K. Noda, Y. Notohara, and K. Kanai, “Magnetic Anisotropies in Sputtered Thin Film Disks,” IEEE, Trans. Magn., Vol.23, pp.3408-3410, September 1987.
9. A. Kawamoto and F. Hikami, “Magnetic Anisotropy of Sputtered Media Induced by Textured Substrate,” J. Appl. Phys., Vol.69, pp.5151-5153, April 1991.
10. E. M. Simpson, P.B. Narayan, G.T.K. Swami, and J.L.Chao, ”Effect of circumferential Texture on the Properties of Thin-Film Rigid Recording Disks,” IEEE, Trans. Magn., Vol.23, pp3405-3407, September 1987.
11. M. L. Williams and R.L. Comstock, “An Analytical Model of the Write Process in Digital Magnetic Recording”, 17th annu, AIP Conf. Prod., 5, pp.738-742,1971.
12. H. N. Bertram, “Fundamentals of the Magnetic Recording Process,” Proc. IEEE, 74(11), pp.1494-1512.
13. E. S. Murdock, R. F. Simons, ”Measured Noise in The Thin Film Media,” Chapter 3, Noise in Digital Magnetic Recording by T. C. Arnoldussen and L. L. Nunnelley, World Scientific, 1992.
14. Y. H. Lee, J. P. Wang, “The Role of Amorphous Ni50P50 Precoating Layer in CoCrPtTa Thin Film Media,” J. Appl. Phys., Vol.87, pp.6346-6348. May (2000).
15. K. E. Johnson, M. Mirzamaami, and M. F. Doerner, ”In Plane Anisotropy in Thin Film Media: Physical Origins of Orientation Ratio (Invited),” IEEE Trans. Magn., MAG-31, No.6, pp.2721-2727,1995.
16. J. J. K. Chang, Fabrication and Characterization of Low Noise Longitudinal Recording Media on Glass Ceramic Substrates”, Ph. D. Thesis in MSE, Stanford University, 1997.
17. S. Foner, Rev. Sci. Instr., 30,548 (1959).
18. B. D. Cullity, Elements of X-RAY DIFFRACTION, Addison-Wesley Publishing, 1978.
19. 林樹均, 葉均藯, 劉增豐, 李勝隆, “材料工程實驗與原理”, 全華科技圖書, 台北市, 1980.
20. 汪建民, “材料分析”, 中國材料科學學會,新竹市,1998.
21. R. P. Ferrier, “Imaging Methods for The study of Micromagnetic Structure,” Chapter5, Noise In Digital Magnetic Recording by T.C. Arnoldussen and L. L. Nunnelley, World Scientific, 1992.
22. Y. Martin and H. K. Wickramasighe,”Magnetic Image by ’Force Microscopy’ with 1000Å Resolution”, Appl. Phys. Lett., 50, pp.1455, 1987.
23. Y. Martin D. W. Abraham, P. C. D.Hobbs and H. K. Wickramasinghe, “Magnetic Force Microscopy – a Short Review”, Electrochemical Society Proc, on Magnetic Materials, Processes and Devices,90~98, pp-115,1989.
24. D. Rugar, H.J. Mamin, P.Guthner, S. E. Lambert, J. E. stern and I. R. McFadyen, ”Magnetic Force Microscopy: General Principles and Applications to Magnetic Recording”, J. Appl. Phys., 68, pp.1169, 1990.
25. G. Choe, J. N. Zhou, B.Demeczyk, M. Yu, M. Zheng, R. Weng., A. Chekanov. “High In-Plane Orientated CoCrPtB Longgitudinal Media for 130 Gb/in2 Recording.” TMRC 2002 Paper B1.
26. Nishikawa. R., T. Hikosaka, K. Igarashi, and M. Kanamaru, “Texture-Induced Magnetic Anisotropy of CoPt films,” IEEE Trans. Magn.,MAG-25,3890 (1989).
27. T. C.Arnodussen, E. M. Rossi, A. Ting, J.Schneider, and G. Trippel, “Obliquely Evaporated Iron-Cobal-Chromium Thin Film Recording Media,” IEEE Trans. Magn., Vol. MAG-20, pp.821-823, September 1984.
28. M.F. Doerner, P.W. Wang, S.M. Mirzamaani, D.S. Parker, and A.C. Wall, “Chromium Underlayer Effects in Longitudinal Magnetic Recording,” Mat. Res. Soc. Symp. Proc., Vol.232, pp27-33, 1991.
29. M. Mirzamaani, K.E. Johnson, D. Edmonson, P. Ivett, and M.Russak, “Orientation Ratio of Sputtered Thin-Film Disks,” J. Appl. Phys., Vol.67, pp4695-4697, May 1990.
30. T.P. Nolan, R. Sinclair, R. Ranjan, and T. Yamashita,”Crystallographic Orientation of Textured CoCrTa/Cr Sputtered Thin film Media for Longitudinal Recording,” J. Appl. Phys., Vol.73, pp.5117-5124, May 1993.
31. D. J. Siconolfi and R. P. Frankenthal, “Air Oxidation of a Ni-P Alloy”, J. Electrochem. Soc., Vol. 136, No. 9, September 1989.
32. M. Mirzamaani, M. Re, S.E. Lambert, A. Praino. T.S. Peterson, and K.E. Johnson, “Signal to Noise Ratio of Thin Film Disks with Various Orientation Ratios,” IEEE Trans. Magn. Vol.26, pp.2457-3459, 1990.
33. C. Denis Mee, Eric D. Daniel, MAGNETIC RECORDING TECHNOLOGY, Second Edition ,1996.

指導教授

李勝隆(Sheng-Long Lee)

審核日期

2003-7-3

推文