以作者查詢圖書館館藏

、以作者查詢臺灣博碩士

、以作者查詢全國書目

、勘誤回報

、線上人數：30

、訪客IP：3.141.32.53

姓名	蔡尚鏞(Shang-Yung Tsai)  查詢紙本館藏	畢業系所	化學工程與材料工程學系
論文名稱	氫氣在甲苯、冰片烯及COC混合溶液 之溶解度量測與關聯 (Solubility of Hydrogen in Mixtures of Toluene, Norbornene, and Cyclic Olefin Copolymer at Various Temperature and Pressures )
相關論文	★ 高速旋轉填充床應用於分離異丙醇-水共沸混合物之研究 ★ 水-醋酸-對位二甲苯-乙酸甲酯-乙酸異丁酯之汽液平衡 ★ 進料不純物作為系統內自體共沸劑模擬回收醋酸之醋酸脫水程序及其效益分析 ★ 單電解水溶液離子活性係數與溫度之關係 ★ 在超臨界CO2之溶解度量測及Poynting factor之探討 ★ 矽酸乙酯與乙醇在不同壓力之相平衡 ★ 水-酚-對甲酚-鄰甲酚四成份系統之液液相平衡研究 ★ 單電解質水溶液離子活性係數之探討 ★ 高速旋轉填充床於分離共沸混合物之研究 ★ 乙烯在甲苯、冰片烯及COC混合溶液之溶解度量測與關聯 ★ 間氯酚與對氯酚之固液相平衡研究 ★ 高速旋轉填充床於分離乙醇-水共沸混合物之研究 ★ 二價單電解質水溶液之個別離子活性係數 量測與關聯 ★ 雙參數個別離子活性係數模式應用於雙電解質水溶液蒸汽壓之估算 ★ β-胡蘿蔔素－二丁基羥基甲苯於超臨界二氧化碳之溶解度量測與關聯 ★ 共溶劑對β-胡蘿蔔素於超臨界二氧化碳溶解度影響之研究
檔案	[Endnote RIS 格式]    [Bibtex 格式]    [相關文章]   [文章引用]   [完整記錄]   [館藏目錄]   [檢視]  [下載] 本電子論文使用權限為同意立即開放。 已達開放權限電子全文僅授權使用者為學術研究之目的，進行個人非營利性質之檢索、閱讀、列印。 請遵守中華民國著作權法之相關規定，切勿任意重製、散佈、改作、轉貼、播送，以免觸法。
摘要(中)	摘 要 光電產業持續成長，新穎技術及新材料需求不斷更新；光學高分子於光電產業用途日漸廣泛與受重視。而環烯烴共聚合物(metallocene catalyzed cyclo-olefin copolymer, COC)材料因具優異之光學特性，宜發展為光學材料。本研究氫-乙烯-冰片烯反應後之產物為環烯烴共聚合物的一種，製程為氫及乙烯在甲苯為溶劑下與冰片烯(norbornene)反應產生COC。明顯的，氫及乙烯在甲苯的溶解度將影響COC的產率及性質。因此本研究將探討不同操作條件下，氫氣之溶解度，再以熱力學模式進行關聯，以增加對未知條件下之預測能力。 本研究為討論不同溫度、壓力下，氫氣在甲苯、冰片烯及COC混合液中溶解情形。實驗將進行在溫度為323.15 K, 373.15 K及423.15 K，壓力為500 kPa(5 bar)至2500 kPa(5 bar)，混合液中冰片烯含量0 wt%至85 wt%，mCOC含量0 wt%至28 wt%之條件下。實驗方法將採用靜態式法。利用平衡槽之壓力變化決定系統之平衡。實驗結果發現氫氣在上述混合溶液中的溶解度將隨壓力上升而增加，但隨溫度上升而下降；不同溫度下，甲苯與冰片烯混合溶液組成比例的不同對氫氣溶解度的影響情形將有所不同；混合溶液中COC的含量增加時，將會使氫氣的溶解度下降。 所得之實驗數據本研究使用 Peng-Robinson 狀態方程式並配合凡得瓦單一流體混合律及Zhong-Masuoka混合律，計算方式採用泡點壓力計算法，進行數據關聯，並求得最佳之雙成分交互作用參數。
摘要(英)	Abstract In this study, the solubilities of hydrogen in mixtures of toluene, norbornene, and cyclic olefin copolymer (COC) were measured at various temperatures (between 323.15 and 423.15 K), pressures (between 5 and 25 bar), concentrations of norbornene (between 0 and 85 wt %), and concentrations of COC (between 0 and 40 wt %). The experiments were conducted by the pressure decaying method using a newly designed apparatus. The experimental results show that the solubility of hydrogen increases with increasing system pressure but decreases with increasing system temperature in the above mixture. Another interesting observation is that the solubility decreases when the concentration of reaction product, COC, is increased. Thus, in addition to temperature and pressure, the COC concentration affects the reaction extent, and beyond a certain COC concentration, further reaction favoring COC generation is impossible because of the opposite effect on hydrogen solubility. Also, in this study, the experimental solubility data were expressed in vapor-liquid equilibrium relationship and correlated by bubble-pressure calculations with the Peng-Robinson equation of state incorporating the modified van der Waals one-fluid(vdW-1) mixing rules and the Zhong-Masuoka mixing rules, including the consideration of binary interaction parameters. The average absolute deviation percentages (AAD) of the correlation are less than 7 %, except that of pressure with the Z-M mixing rules.
關鍵字(中)	★ 熱穩定性 ★ 溶解度 ★ 關聯	關鍵字(英)	★ gas solubility
論文目次	目 錄 中文摘要 Ⅰ 英文摘要 Ⅱ 目錄 Ⅲ 表目錄 Ⅴ 圖目錄 Ⅵ 符號說明 Ⅶ 第一章 緒論 1 1.0 前言 1 1.1 背景說明 1 1.1.1 mCOC之合成方法及應用 1 1.1.2研究動機及目標 2 第二章 理論 3 2.1 汽液相平衡計算 3 2.1.1 汽液相平衡理論 3 2.1.2 逸壓係數 3 2.1.3 汽液平衡上的計算 4 2.2 狀態方程式 5 2.3 混合律 8 2.3.1 Wong-Sandler(W-S)混合律 9 2.3.2單參數凡得瓦單一流體混合律(vdW1) 9 2.3.3 Zhong-Masuoka(Z-M)混合律 10 第三章 文獻回顧 12 3.1 輕質氣體於單一溶劑中之雙成分系統 12 3.2輕質氣體於高分子中之雙成分系統 13 3.3輕質氣體、溶劑與高分子三成分系統 15 第四章 實驗部份 16 4.1 實驗藥品 16 4.2 實驗設備 16 4.3 實驗操作 18 4.3.1 實驗步驟 18 4.3.2 檢量線製作 19 4.4 氫氣溶解度計算 20 4.5 可靠性實驗 21 4.6 高分子相關參數之計算 22 4.7 關聯模式 22 4.7.1 汽液相平衡計算 23 第五章 結果與討論 24 5.1可靠性實驗 24 5.2各組成實驗結果討論 24 5.2.1氫氣與甲苯之雙成分系統 24 5.2.2氫氣、甲苯與冰片烯之三成分系統 25 5.2.3氫氣、甲苯、冰片烯與COC之四成分系統 25 第六章 結論 27 參考文獻 28 表 34 圖 44 Appendix A. Equation of State 55 Appendix B. GCVOL method 58
參考文獻	參考資料 Anderson, T. F. and J. M. Prausnitz, “Application of UNIQUAC Equation to Calculation of Multicomponent Phase Equilibria. 1. Vapor-Liquid Equilibria,” Ind. Eng. Chem. Process. Des. Dev., 1978, 17, pp.552-561 ASPEN PLUS Reference Manual, version 10.1; Aspen-Tech:Cambridge, MA, 2000. Atiqullah, M., H. Hammawa, and H. Hamid, “Modeling the Solubility of Ethylene and Propylene in a Typical Polymerization Diluent：Some Selected Situations,” Eur. Polym. J., 1998, 34, pp.1511-1520 Beaton, C. F., and G. F. Hewitt, “Physical Property Data for the Design Engineer,” Hemisphere, New York, 1989 Behme, S., G. Sadowski, and W. Arlt, “Modeling of the Separation of Polydisperse Polymer Systems by Compressed Gases,” Fluid Phase Equil., 1999, 158-160, pp.869-877 Benedict, M., G. B. Webb, and L. C. Rubin, “An Empirical for Thermodynamic Properities of Light Hydrocarbons,” J. Chem. Phys., 1940, 8, pp.334-352 Benzaghou, S., J. P. Passarello, and P. Tobaly, ”Predictive Use of a SAFT EOS for Phase Equilibria of Some Hydrocarbons and Their Binary Mixtures,” Fluid Phase Equil., 2001, 180, pp.1-26 Beret, S., and J. M. Prausnitz, “Perturbed Hard-Chain Theory：An Equation of State for Fluids Containing Small or Large Molecules,” AIChE J., 1975, 21, pp.1123-1132 Bergström, C. H., and J. V. Seppälä, “Effects of Polymerization Conditions When Making Norbornene-Ethylene Copolymers Using the Metallocene Catalyst Ethylene Bis(indenyl) Zirconium Dichloride and MAO to Obtain High Glass Transition Temperature,” J. App. Polym. Sci., 1997, 63, pp.1063-1070 Bogdanović, V. Ž., A. Ž. Tasić, and B. D. Djordjević, “Inversion Phenomena of Ethylene Solubility in Polyethylene,” J. App. Polym. Sci., 1990, 41, pp.3091-3095 Elbro, H. S., A. Fredenslund, and P. Rasmussen, “Group Contribution Method for the Prediction of Liquid Densities as a Function of Temperature for Solvents, Oligomers, and Polymers,” Ind. Eng. Chem. Res., 1991, 30, pp.2576-2585 Fischer, K., O. Noll, and J. Gmehling, “Experimental Determination of the Oxygen Solubility in Benzene,” J. Chem. Eng. Data, 2001, 46, pp. 1504-1505 Folie, B., C. Gregg, G. Luft, and M. Radosz, “Fluid Equilibria of Poly(Ethylene-co-Vinyl Acetate) Copolymers in Subcritical and Supercritical Ethylene and Ethylene-Vinyl Acetate Mixtures,” Fluid Phase Equil., 1996, 120, pp.11-37 Ghosh, A. W. G. Chapman, and R. N. French, “Gas Solubility in Hydrocarbons -- a SAFT-Based Approach,” Fluid Phase Equilibria, 2003, 209, pp.229-243 Graboski, M. S. and T. E. Daubert, “A Modified Soave Equation of State for Phase Equilibrium Calculation. 1. Hydrocarbon Systems,” Ind. Eng. Chem., 1978, 17, pp.442-451 Josés, V. H., and Z. Artur, “Gas-liquid Solubility of Hydrogen in n-Alcohols (1≦n≦4) at Pressure from 3.6 MPa to 10MPa and Temperatures from 298.15 K to 525.15 K,”J. Chem. Eng. Data, 2001, 46, pp 671-674 King, M. B., D. A. Alderson, F. H. Fallah, D. M. Kassim, K. M. Kassim, J. R. Sheldon, and R. S. Mahmud, “Some Vapour/Liquid and Vapour/Solid Equilibrium Measurements of Releaevance for Supercritical Extraction Operations, and Their Correlation,” in Paulaitis, M. E., J. M. L. Penninger, R. D. Gray, and J. P. Davidson (Eds.),”Chemical Engineering at Supercritical Fluid Conditions,” Ann Arbor Science, 1983, pp.31-80 Kontogeorgis, G. M., V. I. Harismiadis, A. Fredenslund, and D. P. Tassios, “Application of van der Waals Equation of State to PolymersⅠ：Correlation,” Fluid Phase Equil., 1994, 96, pp.65-92 Lee, B. I. and M. G. Kesler, “A Generalized Thermodynamic Correlation Based on Three-Parameter Corresponding State,” AIChE J., 1975, 21, pp.510-521 Lee, L. S., R. F. Shih, H. J. Ou, and T. S. Lee, “Solubility of Ethylene in Mixture of Toluene, Norbornene, and Cyclic Olefin Copolymer at Various Temperatures and Pressures,” Ind. Eng. Chem. Res. 2003, 42, pp.6977-6985 Li, J., Z. Tekie, T. I. Mizan, B. I. Morsi, E. E. Maier, and C. P. P. Singh, “Gas-Liquid Mass Transfer in a Slurry Reactor Operating Under Olefinic Polymerization Process Conditions,” Chem. Eng. Sci., 1996, 51, pp.549-559 Liu, J. L., and D. S. H. Wong, “Application of Wong-Sandler Mixing Rules to Polymer Solutions,” Fluid Phase Equil., 1996, 117, pp.92-99 Louli, V., and D. Tassios, “Vapor-Liquid Equilibrium in Polymer-Solvent Systems With a Cubic Equation of State,” Fluid Phase Equil., 2000, 168, pp.165-182 Michelsen, M. L., “A Method for Incorporating Excess Gibbs Energy Models in Equation of State,” Fluid Phase Equil., 1990, 60, pp.47-58 Mizan, T. I., J. Li, B. I. Morsi , M. Y. Chang, E. Maier, and C. P. P. Singh, “Solubilities and Mass Transfer Coefficients of Gases in Liquid Propylene in Surface-Aeration Agitated Reactor,” Chem. Eng. Sci., 1994, 49, pp.821-830 Ng, H. J., and D. B. Robinson, “Equilibrium Phase Properties of the Toluene-Carbon Dioxide System, ” J. Chem. Eng. Data, 1978, 23, pp.325-327 Nishiumi, H., and S. Saito, “An Improved Generalized BWR Equation of State Applicable to Low Reduced Temperature,” J. Chem. Eng. Japan, 1975, 8, pp.356-360 Orbey, N., and S. I. Sandler, “Vapor-Liquid Equilibrium of Polymer Solution Using a Cubic Equation of State,” AIChE J. 1994, 40, pp.1203-1210 Patel, N. C., and A. S. Teja, “A New Cubic Equation of State for Fluids and Fluid Mixtures,” Chem. Eng. Sci., 1982, 37, pp.463-473 Peng, D. Y., and D. B. Robinson, “A New Two-Constant Equation of State,” Ind. Eng. Chem. Fundam., 1976, 15, pp.59-64 Perry, R. H., and D. Green, “Perry’s Chemical Engineering’s Handbook, 6th,” McGraw-Hill, New York, 1984 Petrova, E., C. Crampon, E. Ali, E. Neau, and E. Badens,” Solubility of CO2 in Some Heavy Alcohols and Correlation of Phase Equilibrium,” Fluid Phase Equilibria, 2003, 213, pp.153-162 Phiong, H. S., and F. P. Lucien, “Solubility of Hydrogen in α-Methylstryene and Cumene at Elevated Pressure,” J. Chem. Eng. Data, 2002, 47, pp 474-477 Pitzer, K. S., D. Z. Lippmann, R. F. Curl, Jr., C. M. Huggins, and D. E. Petersen, “The Volumetric and Thermodynamic Properties of Fluids Ⅱ. Compressibility Factor, Vapor Pressure and Entropy of Vaporization,” J. Am. Chem. Soc., 1955, 77, pp.3427-3438 Prausnitz, J. M., W. C. Edmister, and K. C. Chao, ”Hydrocarbon Vapor-Liquid Equilibria and Solubility Parameter,” AIChE J., 1960, 6, pp.214-223 Prausnitz, J. M., R. N. Lichtenthaler, and E. G. de Azevedo, “Molecular Thermodynamics of Fluid-Phase Eqilibria, 2nd ed.,” Prentice-Hill, Englewood Cliffs, N. J.,1986 Prausnitz, J. M., and F. H. Shair, AIChE J., 1961, 7, pp.682 Radhakrishnan, K., P. A. Ramachandran, P. H. Brahme, and R.V. Chaudharl, “Solubility of Hydrogen in Methanol, Nitrobenzene, and Their Mixture. Experimental Data and Correlation” J. Chem. Data, 1983, 28, pp1-4 Redlich, O., and J. N. S. Kwong, “On the Thermodynamics of Solutions. Ⅴ：An Equation of State. Fugacities of Gaseous Solutions,” Chem. Rev., 1949, 44, pp.233-244 Reid, R. C., J. M. Prausnitz, and B. E. Poling, “The Properties of Gases and Liquids , 4th, Appendix A：Property Data Bank,” McGraw-Hill, 1987 Ruchatz, D., and G. Fink, “Ethene-Norbornene Copolymer Using Homogenous Metallocene and Half-Sandwich Catatlyst : Kinetics and Relationships between Catalyst Structure and Polymer Structure. 1. Kinetics of the Ethene-Norbornene Copolymeerization Using the [(Isopropylidene)(η5-inden-1-ylidene-η5-cyclopentadienyl)]zirconium Dichloride/Methylaluminoxane Catalyst,” Macromolecules, 1998a, 31, pp.4669-4673 Ruchatz, D., and G. Fink, “Ethene-Norbornene Copolymer Using Homogenous Metallocene and Half-Sandwich Catatlyst : Kinetics and Relationships between Catalyst Structure and Polymer Structure. 2. Comparative Study of Different Metallocene- and Half-Sandwich /Methylaluminoxane Catalysts and Analysis of the Copolymer by 13C Nuclear Magnetic Resonance Spectroscopy,” Macromolecules, 1998b, 31, pp.4674-4680 Ruchatz, D., and G. Fink, “Ethene-Norbornene Copolymer Using Homogenous Metallocene and Half-Sandwich Catatlyst : Kinetics and Relationships between Catalyst Structure and Polymer Structure. 3. Copolymerization Parameters and Copolymerization Diagrams,” Macromolecules, 1998c, 31, pp.4681-4684 Ruchatz, D., and G. Fink, “Ethene-Norbornene Copolymer Using Homogenous Metallocene and Half-Sandwich Catatlyst : Kinetics and Relationships between Catalyst Structure and Polymer Structure. 4. Development of Molecular Weights,” Macromolecules, 1998d, 31, pp.4685-4686 Sanchez, I. C., and R. H. Lacombe, “An Elementary Molecular Theory of Classical Fluids. Pure Fluid.,” J. Phys. Chem., 1976, 80, pp.2352-2362 Sandler, S. I., “Chemical and Engineering Thermodynamics, 3rd,” Wiley, 1999 Saraiva, A., G. M. Kontogeorgis, V. I. Harismiadis, A. Fredenslund, and D. P. Tassios, “Application of van der Waals Equation of State to Polymers Ⅳ：Correlation and Prediction of Lower Critical Solution Temperatures for Polymer Solutions ,” Fluid Phase Equil., 1996, 115, pp.73-93 Sato, Y., K. Fujiwara, T. Takikawa, Sumarno, S. Takishima, and H. Masuoka, “Solubilities and Diffusion Coefficients of Carbon Dioxide and Nitrogen in Polypropylene, High-Density Polyethylene, and Polystyrene under High Pressures and Temperatures,” Fluid Phase Equil., 1999, 162, pp.261-276 Sato, Y., M. Yurugi, K. Fujiwara, S. Takishima, and H. Masuoka, “Solubilities of Carbon Dioxide and Nitrogen in Polystyrene under High Temperature and Pressure,” Fluid Phase Equil., 1996, 125, pp.129-138 Simnick, J. J., H. M. Sebastian, H. M. Lin, and K. C. Chao, “Solubility of Hydrogen in Toluene at Elevated Temperature and Pressure,” J. Chem. Eng. Data, 1978, 23, pp. 339-340 Soave, G., “Equilibrium Constants from a Modified Redlich-Kwong Equation of State,” Chem. Eng. Sci., 1972, 27, pp.1197-1207 Tan, Z. Q., G. H. Gao, Y. X. Yu, and C. Gu, “Solubility of Oxygen in Aqueous Sodium Carbonate Solution at Preaaure up to 10MPa,”Fluid Phase Equilibria, 2001, 180, pp375-382 Tasibanogiannis, I. N., K. S. Kalospiros, and D. P. Tassios, “Extension of the GCVOL Method and Appliciation to Some Complex Compounds,” Ind. Eng. Chem. Res., 1994, 33, pp.1641-1643 Teja, A. S., “A Corresponding-State Equation for Saturated Liquid Densities.Ⅰ. Applications to LNG,” AIChE J., 1980, 26, pp.337-345 Tyvina, T. N., A. A. Naumova, and S. A. Polyakov, “Critical Effects and Phase and Volume Behavior of Ethylene in Toluene,” J. App. Chem. Ussr, 1979, 52, pp.910-913 Wilson, G. M., “Vapor-Liquid Equilibrium. XI. A New Expression for the Excess Free Energy of Mixing,” J. Am. Chem. Soc., 1964, 86, pp.127-130 Wong, D. S. H., and S. I. Sandler, “A Theoretically Correct Mixing Rule for Cubic Equation of State,” AIChE J., 1992, 38, pp.671-680 Zhong C., and H. Masuoka, “A New Mixing Rule for Cubic Equation of State and its Application to Vapor-Liquid Equilibria of Polymer Solutions,” Fluid Phase Equil., 1996a, 123, pp.59-69 Zhong C., and H. Masuoka, “Prediction of Henry’s Constants for Polymer-Containing Systems using the SRK Equation of State Coupled with a New Modified UNIFAC Model,” Fluid Phase Equil., 1996b, 126, pp.1-12 Zhong C., and H. Masuoka, “Modeling of Gas Solubilities in Polymers with Cubic Equation of State,” Fluid Phase Equil., 1998, 144, pp.49-57 李育德, 顏文義, 莊祖煌, “聚合物物性, ” 高立圖書, 民國85年 洪士民, “高溫高壓下二氧化碳-正烷基梭酸雙成分系統之氣液相平衡,” 國立成功大學化學工程研究所碩士論文, 台南, 民國86年 黃辰寶, “高溫高壓下之氣液相平衡—甲烷與重正烷烴之雙成分系統,” 國立成功大學化學工程研究所碩士論文, 台南, 民國79年 楊思廉, “工業化學概論, 第十三章 塑膠工業,” 高立圖書, 民國71年 鄭孟勳, “以有機茂金屬觸媒合成丙烯-原乙烯之COC共聚物及其物性探討,” 國立中央大學化學研究所碩士論文, 中壢, 民國89年
指導教授	李亮三(Liang-Sun Lee)	審核日期	2004-7-15
推文	facebook   plurk   twitter   funp   google   live   udn   HD   myshare   reddit   netvibes   friend   youpush   delicious   baidu
網路書籤	Google bookmarks   del.icio.us   hemidemi   myshare