從纖維公司釋放的亞硫酸鹽和次氯酸鹽對廢水處理廠的性能和邊際減排成本的影響 以 印 度 尼 西 亞 的 Purwakarta 為 例

以作者查詢圖書館館藏

、以作者查詢臺灣博碩士

、以作者查詢全國書目

、勘誤回報

、線上人數：88

、訪客IP：18.191.178.16

姓名

葵薇蘿(An-Nuur Taqwayaroh Wamayataqillah) 查詢紙本館藏

畢業系所

國際永續發展碩士在職專班

論文名稱

從纖維公司釋放的亞硫酸鹽和次氯酸鹽對廢水處理廠的性能和邊際減排成本的影響以印度尼西亞的 Purwakarta 為例
(Effect of Sulphite and Hypochlorite Released from a Fiber Company on the Performance and Marginal Abatement Cost of a Waste Water Treatment Plant Case Study: Purwakarta, Indonesia)

相關論文

★ 埔心溪補助灌溉水水質與渠道底泥重金屬含量調查分析	★ 桃園航空城三所國小周界大氣PAHs濃度探討
★ 無塵室揮發性有機氣體異味調查探討 -以某晶圓級封裝廠為例	★ 利用土壤植栽與固相微萃取探討植作對非離子態有機污染物之吸收模式
★ 零價鐵與硫酸鹽的添加對於水田根圈環境汞之生物有效性與菌相組成的影響	★ 以紫外光/二氧化鈦光催化降解程序去除水溶液相內分泌干擾物質壬基苯酚之研究
★ 異化性鐵還原狀態下非生物性汞氧化還原作用及其對地下水水質之影響	★ 水溶液相中多壁奈米碳管分散懸浮與抑菌效果之相關性探討
★ 鄰近汞排放源之水稻田受現地地質化學與微生物影響之甲基汞生成與累積作用-以北投垃圾焚化爐為例	★ 以淨水污泥灰及廢玻璃為矽鋁源合成MCM-41並應用於重鉻酸鹽吸附之研究
★ 鄰近汞排放源之水稻田受現地地質化學與微生物影響之甲基汞生成與累積作用 -以台中火力發電廠為例	★ 細胞固定化影響厭氧氨氧化程序脫氮效能之研究
★ 藉由非抗性模式細菌對鎘之攝取機制探討量子點的生態毒性潛勢	★ 利用生物性聚合物交聯所成穿透式網絡結構穩定污染土壤中之重金屬(鉛、鉻、鎘)
★ 蚯蚓處理加速堆肥廚餘去化可行性評估-以臺北市為例	★ 氣相層析三段四極柱串聯質譜儀應用於多溴二苯醚環境樣品之分析

檔案

[Endnote RIS 格式]

[Bibtex 格式]

[相關文章]

[文章引用]

[完整記錄]

[館藏目錄]

[檢視]

[下載]

本電子論文使用權限為同意立即開放。
已達開放權限電子全文僅授權使用者為學術研究之目的，進行個人非營利性質之檢索、閱讀、列印。
請遵守中華民國著作權法之相關規定，切勿任意重製、散佈、改作、轉貼、播送，以免觸法。

摘要(中)

印度尼西亞Purwakarta城市的纖維公司所排放的高濃度亞硫酸鹽和次氯酸鹽廢水一直以來被認為是導致當地污水處理廠出水水質不佳的原因。為了確定廢水處理的亞硫酸鹽和氯的濃度限制，本研究使用Minitab 16模式分析了入流水的亞硫酸鹽及氯化物濃度與廢水處理效能之間的關係。廢水處理效能以一系列的關鍵水質參數做評估，包括化學需氧量（COD），生物需氧量（BOD），混合液懸浮固體（MLSS）和混合液體揮發性懸浮固體（MLVSS）。此外，還評估了COD和BOD排放的邊際減排成本（MAC）。結果發現，亞硫酸鹽濃度的可接受範圍為4483.19至5237.085 mg/L之間，氯濃度的極限範圍則為0.27至0.31 mg/L之間。至於MAC的減排成本，1 mg/L的COD估計為Rp.55,849.14，而BOD則為Rp.55,845.51。本研究的成果可作為未來廢水處理廠審查和修訂的參考。

摘要(英)

Elevated concentrations of sulphite and hypochloride released from fiber industry have been considered the factors to cause poor effluent water quality of the wastewater treatment plant in Purwakarta, Indonesia. To determine the concentration limit of sulphite and chlorine for the wastewater treatment, in this study we analyzed the association between the influent sulphite or chloride concentration and the performance of the wastewater treatment by using Minitab 16 programs. A suite of key water quality parameters including Chemical Oxygen Demand (COD), Biological Oxygen Demand (BOD), Mixed Liquor Suspended Solids (MLSS) and Mixed Liquor Volatile Suspended Solids (MLVSS) were included in the analysis. In addition, Marginal Abatement Cost (MAC) from COD and BOD emission was assessed. It was found that the acceptable range for sulphite concentrations was 4483.19 mg/L to 5237.085 mg/L and the limit range of chlorine concentrations was 0.27 – 0.31 mg/L. The estimated abatement cost of MAC for 1 mg/l COD parameter was Rp.55, 849.14 and for that of BOD was Rp.55, 845.51. This study may serve as a reference for future review and revision of the Wastewater Treatment Plant.

關鍵字(中)

★ 纖維工業
★ 進流水亞硫酸鹽和次氯酸鹽
★ 濃度限制
★ 廢水處理過程和邊際減排成本。

關鍵字(英)

★ fiber industry
★ influent sulphite and hypochlorite
★ the wastewater treatment process
★ and marginal abatement cos

論文目次

Chinese Abstract i
Abstract ii
Acknowledgement iii
Table of Contents iv
List of Figures vii
List of tables ix
Acronyms x
Chapter 1 Introduction 1
1.1 Problem Statement 1
1.2 Cause and Mechanism of problem 2
1.3 Solution of the Problem 2
1.4 Purpose of this Study 3
1.5 Benefit of this Study 4
Chapter 2 Literature Review 5
2.1 The Wastewater for fibre Company 5
2.1.1 Source of fibre Industry waste 5
2.1.2 Parameters of Wastewater from Textile Industry 8
2.2 Liquid Waste 10
2.3 Sulphite 10
2.4 Hypochlorite 11
2.5 Waste Water Treatment Process 12
2.6 Sulphur Process in Waste Water 17
2.7 Equalization Unit of Liquid Waste Processing 20
2.8 Active Sludge Unit on Industrial Waste Water Treatment 21
2.9 Abatement Cost 25
2.9.1 Aggregate Marginal Abatement Cost 27
2.10 Minitab 28
Chapter 3 Methodology 29
3.1 Flowchart Procedure of the Research 29
3.2 Analyse Sulphite and Chlorine Concentration 30
3.2.1 Method of implementation… 30
3.2.2 Data Analysis 30
3.3 Determine the Efficiency for BOD and COD Emission 31
3.4 Marginal Abatement Cost… 32
3.4.1 Types and Data Sources 32
3.4.2 Methods and Data Analysis 32
3.4.3 Marginal Abatement Cost (MAC) Analysis based on
Liquid Waste Parameter Concentration 32
3.4.4 Estimated Equation and Marginal Abatement Cost Curves (MAC)… 35
Chapter 4 Result and Discussion 37
4.1 Location of Fiber Company 37
4.2 Liquid Waste management and Management Regulations 37
4.3 The Process for making Fibers on Fiber Company 38
4.4 waste Water Treatment Production 39
4.5 Description Design of Liquid Waste Water Processing Unit in Fiber Company 42
4.6 Efficiency of Waste Water Treatment fir BOD and COD… 43
4.6.1 BOD (Biochemical Oxygen Demand) 43
4.6.2 COD (Chemical Oxygen Demand)… 44
4.7 Parameter Control of Liquid waste Pollutant Processing 45
4.8 Analysis Sulphite and Chlorine Concentration in wastewater Treatment Plant … 46
4.8.1 Sulphite Concentration for 24 hours 46
4.8.2 Chlorine Concentration for 24 hours 47
4.8.3 Analysis for Sulphite Concentration on Water Parameters 48
4.8.4 Analysis for Chlorine Concentration on Water Parameters… 55
4.9 Pre-treatment for Sulphite and Chlorine Concentration… 62
4.10 Estimated Marginal Abatement Cost (MAC) based on Wastewater Parameters. 63
4.10.1 Inlet and Outlet waste Water based on Parameters… 63
4.10.2 Total Cost of Waste Water Processing (Total Abatement Cos/TAC)… 64
4.10.3 Estimated Marginal Abatement Cost (MAC) of BOD Parameters… 65
4.10.4 Estimated Marginal Abatement Cost (MAC) of COD Parameters… 68
Chapter 5 Conclusion and Recommendation 71
5.1 Conclusion 71
5.2 Recommendation 71
References 72
Appendixes. 75

參考文獻

Abidin, Z., Iryani, A., dan Mulyati, A.H. (2012).Perbandingan Penggunaan PAC dan Alum Sebagai Koagulan Pada Air Limbah Industri PT. Nalco Indonesia.

Ajang , (2012).Pengolahan sederhana limbah tekstil. http://ajangsopyan.blogspot.com/2012/01/pengolahan-sederhana-limbah-tekstil.html

Barry C.F and Martha K.F, (2017).Environmental Economics: An Introduction, seventh Edition. McGraw-Hill education International Edition. New York.

Cancino-Madariaga, B., dan Aguirre, J. (2011).Combination Treatment of Corn Starch Wastewater by Sedimentation, Microfiltration and Reverse Osmosis. Desalination, Vol. 279, No. 1, Hal. 285–90.

Carlsson, B. (1998). An Introduction to Sedimentation Theory in Wastewater Treatment. Systems and Control Group, Uppsala University

Damanhuri,E.,E Padmi , T. (2008). Wastewater management.

European Commision.(2003). Integrated Pollution Prevention and Control (IPPC)
Reference Document on Best Available Techniques for the Textiles Industry.
http://www.prtr-es.es/data/ images/textil-9D85EDBFC0238544.pdf

Field, B.C. (1994). Environmental Economics : An Introductory. McGraw-Hill, Inc.Singapura.

Fisher et al.(2017). Sulfur flows and biosolids processing: Using Material Flux Analysis
(MFA) principles at wastewater treatment plants. Journal of Environmental Management
198 (2017) 153e162
Hamoda, M, Al-Ghusain, I., dan Iryani, A., dan Djoko Hartanto (2017). Textile Dyes Removal By ZSM-5 From Bangka

Iriawan Nur dan Septin, PA. (2006). Mengolah Data Statistik Dengan Mudah Menggunakan Minitab 14. Andi Offset. Yogyakarta

Kaolin” Manai, I., Miladi, B., El Mselmi, A., Hamdi, M., dan Bouallagui, H. (2017), “Improvement of Activated Sludge Resistance to Shock Loading by Fungal Enzyme Addition during Textile Wastewater Treatment.” Environmental Technology,
Vol. 38, No. 7, Hal. 880– 90.

Lebrecht, Timothy. (2015). Treating Sulfur in Wastewater.
http://www.airproducts.com/~/media/downloads/w/wastewatertreatment/data-
sheets/en-treating-sulfur-in-wastewater.pdf.

Kemenpri.(2007).Standard waste for waste management: Government regulation figures
for 2007.

MetCalf and Eddy. (1991). Waste Water Engineering. Mc Graw Hill.

MetCalf and Eddy. (2014). Waste Water Engineering. Mc Graw Hill

Mara, D. (2013). Domestic Wastewater Treatment in Developing Countries, Routledge,

Ochowiak, M., Matuszak, M., W?odarczak, S., Ancukiewicz, M.,dan Krupi?ska, A. (2017),
“The Modified Swirl Sedimentation Tanks for Water Purification.” Journal of Environmental Management, Vol. 189, No. Supplement C, Hal. 22–28.

Orhon, Derin. (2001). A scientific approach to wastewater recovery and reuse in the textile
Company .https://www.researchgate.net/publication/11897284_A_scientific_approa ch_to_wastewater_recovery_and_reuse_in_the_textile_company

Purnamasari, Riska Devi., Iryani, Ani & Aminingsih, Tri. (2015). Pemanfaatan Kacang Babi
(Vicia faba) dan Biji Asam Jawa (Tamarindus indica L) Sebagai Koagulan Alami Pada
Proses Perbaikan Kualitas Air". Program Studi Kimia Fakultas MIPA UNPAK

Rajamanickam, R., dan Baskaran, D. (2017), Biodegradation of Gaseous Toluene with
Mixed Microbial Consortium in a Biofilter: Steady State and Transient Operation.
Bioprocess and Biosystems Engineering, Vol. 40, No. 12, Hal. 1801–12.

Riffat, R. (2012), Fundamentals of Wastewater Treatment and Engineering, CRC Press,

RKL.(2012). Laporan Pelaksanaan RKL dan RPL. Purwakarta.

Roslev, P., Vorkamp, K., Aarup, J., Frederiksen, K., dan Nielsen, P.H. (2007). Degradation
of Phthalate Esters in an Activated Sludge Wastewater Treatment Plant. Water Research,
Vol. 41, No. 5, Hal. 969–76.

R. Yuwono dan E. Adinugroho, (2010). Buku Pegangan Manajer Pengendalian
Pencemaran Air, Badan Pengendalian Lingkungan Hidup Daerah Provinsi Jawa
Barat,Bandung,

Samer, M. (2015), Biological and Chemical Wastewater Treatment Processes.
Wastewater Treatment Engineering, Ch. 01InTech,

Sdiri, A., Higashi, T., Jamoussi, F., dan Bouaziz, S. (2012), Effects of Impurities on the Removal of Heavy Metals by Natural Limestones in Aqueous Systems. Journal of Environmental Management, Vol. 93, No. 1, Hal. 245–53.

Sperling, M.V.(2007) .Activated sludge and aerobic biofilm reactor.Department of Sanitary and Environment Engineering, Federal University of Minas Gerais, Brazil,

Srivastava, N.K., dan Majumder, C.B. (2008), Novel Biofiltration
Methods for the Treatment of Heavy Metals from Industrial Wastewater.” Journal of Hazardous Materials, Vol. 151, No. 1, Hal. 1–8.

Sterrit. R.M and Lester.J.N. (1998). Microbiology for Environmental and Public Health Engineers , E,&F,N Spon Ltd, London

USEPA.(2007). Waste Diversion . Retrieved October 16, 2017, from http://www.epa.gov/wastewaterepa/waste/

指導教授

林居慶(Chu-Ching Lin, Ph.D)

審核日期

2018-8-20

推文