諧振電容控制之LLC諧振轉換器設計與實現

以作者查詢圖書館館藏

、以作者查詢臺灣博碩士

、以作者查詢全國書目

、勘誤回報

、線上人數：22

、訪客IP：18.220.123.26

姓名

陳?龍(Jyue-Long Chen) 查詢紙本館藏

畢業系所

電機工程學系

論文名稱

諧振電容控制之LLC諧振轉換器設計與實現
(Design and Implementation of Resonant Capacitor Controlled LLC Resonant Converter)

相關論文

★ 感光式觸控面板設計	★ 單級式直流無刷馬達系統之研製
★ 單級高功因LLC諧振電源轉換器之研製	★ 多頻相位編碼於穩態視覺誘發電位之大腦人機介面系統設計
★ 類神經網路於切換式磁阻馬達轉矩漣波控制之應用	★ 感應馬達無速度感測之直接轉矩向量控制
★ 具自我調適導通角度功能之切換式磁阻馬達驅動系統---DSP實現	★ 感應馬達之低轉速直接轉矩控制策略
★ 加強型數位濾波器設計於主動式噪音控制之應用	★ 非匹配不確定可變結構系統之分析與設計
★ 無刷直流馬達直接轉矩控制方法之轉矩漣波改善	★ 無轉軸偵測元件之無刷直流馬達驅動器研製
★ 無轉軸偵測元件之開關磁阻馬達驅動系統研製	★ 感應馬達之新型直接轉矩控制研究
★ 同步磁阻馬達之性能分析及運動控制研究	★ 改良比例積分與模糊控制器於線性壓電陶瓷馬達位置控制

檔案

[Endnote RIS 格式]

[Bibtex 格式]

[相關文章]

[文章引用]

[完整記錄]

[館藏目錄]

[檢視]

[下載]

本電子論文使用權限為同意立即開放。
已達開放權限電子全文僅授權使用者為學術研究之目的，進行個人非營利性質之檢索、閱讀、列印。
請遵守中華民國著作權法之相關規定，切勿任意重製、散佈、改作、轉貼、播送，以免觸法。

摘要(中)

本論文主要研製一具功率因數修正之半橋LLC諧振轉換器，傳統LLC諧振轉換器具有輕載效率較低的問題，此問題通常會採用Burst-mode來解決，但使用Burst-mode解決輕載效率較低的問題會有輸出漣波大、噪音、動態響應差等問題，所以本論文使用諧振電容控制來達到輕載效率改善的效果；此外，此控制方法也可用於延長維持時間。最後，本論文實作出一台300W之AC/DC電源供應器，其輸入電壓為90 ~ 264 Vac，輸出電壓50 Vdc，滿載輸出電流6 A，整體平均功因達0.94以上，平均效率可達90%，最高效率達93%，相關實驗結果驗證所設計之具功率因數修正之諧振電容控制之半橋LLC諧振轉換器具有改善輕載效率及延長維持時間之效果。

摘要(英)

This thesis focuses on the design and implementation of a half-bridge LLC resonant converter with power factor correction. The traditional LLC resonant converter suffer from the problem of poor light-load efficiency. Burst-mode is usually used to solve this problem, but Burst-mode has problems like large output voltage ripple, acoustic noise, poor dynamic response. This thesis proposes a resonant capacitor controlled LLC resonant converter to improve light-load efficiency. In addition, this control method can be used to extend hold-up time. Finally, this thesis implements a 300W AC/DC power supply. The input voltage range is 90 ~ 264V_ac, the output voltage is 50V_dc, and the output current is 6 A at full-load. The overall average power factor is more than 0.94. The average efficiency is 90%, and the highest efficiency is 93%. Finally, the relevant experimental results verify that the designed resonant capacitor controlled half-bridge LLC resonant converter with power factor correction has the effect of improving light load efficiency and extending the hold-up time.

關鍵字(中)

★ LLC諧振轉換器
★ 升壓型功率因數修正器
★ 諧振電容控制
★ 輕載效率改善
★ 延長維持時間

關鍵字(英)

★ LLC resonant converter
★ boost power factor corrector
★ resonant capacitor control
★ light-load efficiency improvement
★ extend hold-up time

論文目次

摘要 i
Abstract ii
誌謝 iii
目錄 iv
圖目錄 vii
表目錄 xi
第一章緒論 1
1-1前言 1
1-2研究動機與目的 2
1-3文獻回顧 3
1-4內容大綱 5
第二章功率因數修正器之原理 6
2-1功率因數之定義 6
2-2功率因數修正器之電路架構 9
2-3升壓型功率因數修正器之電路分析與設計 10
2-4升壓型功率因數修正器之控制方法 14
第三章 LLC諧振轉換器之原理與分析 17
3-1開關的切換損失 17
3-2電路架構 18
3-3動作原理 21
3-4特性分析 29
3-4-1電壓增益函數分析 30
3-4-2 K值、Qe值對電壓增益的影響 34
3-4-3輕載效率低下分析 39
3-4-4 K值與效率及維持時間的取捨 41
第四章諧振電容控制分析 42
4-1輕載效率改善原理 42
4-2維持時間延長原理 44
第五章整體電源轉換器之設計 45
5-1 升壓型功率因數修正器電路規格設計 46
5-1-1升壓型功率因數修正器之元件參數設計 47
5-1-2升壓型功率因數修正器之PSIM模擬 50
5-2 LLC諧振轉換器電路規格設計 52
5-2-1 LLC諧振轉換器之元件參數設計 54
5-2-2 LLC諧振轉換器之PSIM模擬 63
第六章實驗結果與討論 65
6-1 升壓型功率因數修正器之波形 66
6-2 半橋LLC諧振轉換器之波形 71
6-3 整體電源轉換器之數據量測 79
6-4 整體電源轉換器之損失分析 83
第七章結論與未來展望 84
參考文獻 85

參考文獻

[1] W. J. Gu and K. Harada, “A new method to regulate resonant converters,” IEEE Trans. on Power Electronics, vol. 3, no. 4, pp. 430-439, 1988.
[2] A. K. S. Bhat, “Analysis, optimization and design of a series-parallel resonant converter,” in Proc. IEEE APEC, pp. 155-164, 1990.
[3] F. C. Lee, “High-frequency quasi-resonant converter technologies,” Proceedings of the IEEE, vol. 76, no. 4, pp. 377-390, 1988.
[4] K. H. Liu and F. C. Lee., “Zero-voltage switching technique in DC-DC converters,” IEEE Trans. on Industrial Electronics, vol. 5, no. 3, pp. 293-304 1986.
[5] R. Liu, and C. Q. Lee, “Analysis and design of LLC-type series resonant convertor,” IEE Electron Letter, vol. 24, no.24 , pp. 1517 -1519,1988
[6] Energy Star, 2007: http://www.energystar.gov/
[7] European Commission, 2007: http://ec.europa.eu/index_en.htm
[8] B. Wang, X. Xin, “Analysis and Implementation of LLC Burst Mode for Light Load Efficiency Improvement,” in Proc. IEEE APEC, pp. 58-64, 2009.
[9] W. Feng, F.-C. Lee, “LLC resonant converter burst mode control with constant burst time and optimal switching pattern,” in Proc. IEEE APEC, pp. 6-12, 2011.
[10] R. Beiranvand, “Optimizing the LLC–LC Resonant Converter Topology for Wide-Output-Voltage and Wide-Output-Load Applications,” IEEE Trans. on Power Electronics, vol. 26, pp. 3192-3204, 2011
[11] S. Kim and P. N. Enjeti, “A Modular Single-Phase Power-Factor- Correction Scheme With a Harmonic Filtering Function,” IEEE Trans. on Industrial Electronics, vol. 50, No. 2, pp. 328-335, Apr., 2003.
[12] N. Mohan, T.-M. Undeland, and W.-P. Robbins, “Power electronics,” Third Edition, John Wiley & Sons, 2002.
[13] K. Raggl, T. Nussbaumer, G. Doerig, J. Biela and J. W. Kolar, “Comprehensive Design and Optimization of a High-Power-Density Single-Phase Boost PFC,” IEEE Trans. on Power Electronics, vol. 56, pp. 2574-2587, Jul., 2009.
[14] M. Matsuo, K. Matsui, I. Yamamoto and F. Ueda, “A comparison of various DC-DC converters and their application to power factor correction,” IEEE Industrial Electronics Society, vol. 2, pp. 1007-1013, Oct., 2000.
[15] M. S. Dawande and G. K Dubey, “Programmable input power factor correction method for switch-mode rectifiers,” IEEE Trans. on Power Electronics, vol. 11, pp. 585-591, Jul., 1996.
[16] C. A. Canesin, and I. Barbi, “Analysis and Design of Constant-Frequency Peak-Current-Controlled High-Power-Factor Boost Rectifier with Slope Compensation,” in Proc. IEEE APEC, pp. 807-813, 1996.
[17] P. J. Villegas, J. Sebastian, M. Hernando, F. Nuno and J. A. Martinez, “Average current mode control of series-switching post-regulators used in power factor correctors,” IEEE Trans. on Power Electronics, vol. 15, pp. 813-819, Sept., 2000.
[18] R. Srinivasan and R. Oruganti, “ A unity power factor converter using half-bridge boost topology,”IEEE Trans. on Power Electronics, vol. 13, No. 3, pp. 487-500, May, 1998.
[19] L. Huber, B. T. Irving and M. M. Jovanovic, “Open-loop control methods for interleaved DCM/CCM boundary boost PFC converters,” IEEE Trans. on Power Electronics, vol. 23, No. 4, pp. 1649-1657, Jul., 2008.
[20] J. W. Kim, S. M. Choi and K. T. Kim, ”Variable on-time control of the critical conduction mode boost power factor correction converter to improve zero-crossing distortion,” in Proc. IEEE PEDS, pp. 1542-1546, 2005.
[21] G. C. Chryssis, “High Frequency Switching Power Supplies: Theory & Design,” McGraw-Hill, 1989.
[22] A. I. Pressman, “Switching Power Supply Design,” Second Edition, McGraw-Hill, 1999.
[23] G. C Hsieh, C. Y. Tsai, and S. H. Hsieh, “Design considerations for LLC series-resonant converter in two-resonant regions,” in Proc. IEEE PESC, pp. 731-736, 2007.
[24] Jae-Bum Lee, Jae-Kuk Kim, Jae-Il Baek, Jae-Hyun Kim, Gun-Woo Moon, “Resonant Capacitor On/Off Control of Half-Bridge LLC Converter for High-Efficiency Server Power Supply” IEEE Trans. on Industrial Electronics, vol. 63, No. 9, Sep., 2016.
[25] 楊庭越，「具功因修正之半橋LLC諧振轉換器設計與實現」，國立中央大學電機工程學系，碩士論文，民國106年6月。
[26] 溫雅婷，「LLC諧振轉換器設計與實現」，國立中央大電機工程學系，碩士論文，民國105年6月。
[27] Shu Zhong, Jianping Xu, Sheng Zhao, Xiang Zhou, “Bi-frequency control for LLC resonant converter with fast transient response” ELECTRONICS LETTERS 29th September 2016 Vol. 52 No. 20 pp. 1710–1712333.
[28] Zhiyuan Hu, Laili Wang, Yan-Fei Liu, P. C. Sen, “Bang-Bang Charge Control for LLC Resonant Converters” IEEE Transactions on Power Electronics Volume: 30, Issue: 2, Feb. 2015.

[29] Haoyu Wang, Zhiqing Li, “A PWM LLC Type Resonant Converter Adapted to Wide Output Range in PEV Charging Applications” IEEE Transactions on Power Electronics Volume: 33, Issue: 5, May 2018.
[30] B.-R. Lin, J.-J. Chen, C.-L. Yang, “Analysis and implementation of dual-output LLC resonant converter” 2008 IEEE International Conference on Industrial Technology.
[31] Haiyan Pan, Chao He, Farooq Ajmal, Henglin Chen, Guozhu Chen, “Pulse-width modulation control strategy for high efficiency LLC resonant converter with light load applications” IET Power Electron., 2014, Vol. 7, Iss. 11, pp. 2887–2894.
[32] J.-W. Kim, J.-K. Han and J.-S. Lai, “APWM adapted half-bridge LLC converter with voltage doubler rectifier for improving light load efficiency”
ELECTRONICS LETTERS 2nd March 2017 Vol. 53 No. 5 pp. 339–341.

指導教授

徐國鎧(Kuo-Kai Syu)

審核日期

2018-7-24

推文