類弦波反電動式無刷直流馬達之SVPWM研究

以作者查詢圖書館館藏

、以作者查詢臺灣博碩士

、以作者查詢全國書目

、勘誤回報

、線上人數：81

、訪客IP：52.15.72.229

姓名

邱瑋國(Ciou,Wei-Guo) 查詢紙本館藏

畢業系所

電機工程學系

論文名稱

類弦波反電動式無刷直流馬達之SVPWM研究
(Non-sinusoidal back electromotive force brushless DC motor of SVPWM research)

相關論文

★ 感光式觸控面板設計	★ 單級式直流無刷馬達系統之研製
★ 單級高功因LLC諧振電源轉換器之研製	★ 多頻相位編碼於穩態視覺誘發電位之大腦人機介面系統設計
★ 類神經網路於切換式磁阻馬達轉矩漣波控制之應用	★ 感應馬達無速度感測之直接轉矩向量控制
★ 具自我調適導通角度功能之切換式磁阻馬達驅動系統---DSP實現	★ 感應馬達之低轉速直接轉矩控制策略
★ 加強型數位濾波器設計於主動式噪音控制之應用	★ 非匹配不確定可變結構系統之分析與設計
★ 無刷直流馬達直接轉矩控制方法之轉矩漣波改善	★ 無轉軸偵測元件之無刷直流馬達驅動器研製
★ 無轉軸偵測元件之開關磁阻馬達驅動系統研製	★ 感應馬達之新型直接轉矩控制研究
★ 同步磁阻馬達之性能分析及運動控制研究	★ 改良比例積分與模糊控制器於線性壓電陶瓷馬達位置控制

檔案

[Endnote RIS 格式]

[Bibtex 格式]

[相關文章]

[文章引用]

[完整記錄]

[館藏目錄]

[檢視]

[下載]

本電子論文使用權限為同意立即開放。
已達開放權限電子全文僅授權使用者為學術研究之目的，進行個人非營利性質之檢索、閱讀、列印。
請遵守中華民國著作權法之相關規定，切勿任意重製、散佈、改作、轉貼、播送，以免觸法。

摘要(中)

本研究討論馬達只有霍爾傳感器情況下，使用基礎的空間向量脈波寬度調變，相較於六步控制可以提升馬達在各轉速與負載下的效率、並使馬達對於外部負載變化可以有更好的響應、提高馬達最大力矩輸出；另外地提出空間向量脈波寬度調變電壓向量的，排列方式調整以減少反流器切換損耗，並配合三相電流流動方向調整電壓向量的排列方式，藉由電壓向量排列方式與三相電流方向，調控MOS開關切換方式提高馬達運轉時效率。

市售的無刷馬達的反電動勢從標準梯形波到弦波都可以出現，甚至帶有諧波成分的類弦波，本研究針對個別馬達反電動勢進行波形分析，將具有諧波成分經過演算法加入空間向量脈波寬度調變，讓調整過的空間向量脈波寬度調變驅動對應馬達時可以有較理想的相電流，並使用噪音計量測六步方波控制、SVPWM、調整後SVPWM，三種控制方法在運轉時噪音大小，驗證馬達運轉時高頻噪音的差異。

摘要(英)

The study consider the motor only with the Hall sensor motor, and still can use under different the space vector pulse width modulation to improve motor efficiency speed and load infinite compared with six-steps control. The designed SVPWM could increase the maximum torque output. Also, properly arranging the SVPWM voltage vector pattern can reduce switching loss. In accordance with the motor three-phase current, this study adjusts the SVPWM voltage vector pattern. To reducing switching losses and enhance the motor efficiency.

The back-EMF of brushless DC motor include trapezoidal wave, sine wave, and even sine wave with harmonic components. The study analysis motor back-EMF first, and then add the harmonic components into the space vector pulse width modulation. Thus the adjusted space vector pulse width modulation drive can have more ideal motor phase current. Moreover, a sound meter is used to measure noises induced by six-step control, SVPWM, adjusted SVPWM.

關鍵字(中)

★ SVPWM
★ 反電動勢
★ 諧波分析
★ 切換損耗
★ 無刷馬達

關鍵字(英)

★ SVPWM
★ back-EMF
★ harmonic component
★ switching loss
★ BLDC

論文目次

目錄

摘要 I

ABSTRACT II

誌謝 III

目錄 IV

圖目錄 VI

表目錄 IX

第１章緒論 1

1.1 研究動機與目的 1

1.2 大綱 3

第２章無刷馬達介紹 4

2.1 前言 4

2.2 無刷直流馬達與永磁同步馬達簡介 4

2.2.1 無刷直流馬達介紹 4

2.2.2 無刷直流馬達數學模式 5

2.2.3 永磁同步馬達介紹 8

2.2.4 永磁同步馬達數學模式 9

2.3 本文研究之馬達介紹 16

第３章控制電路設計 18

3.1 MOSFET介紹 18

3.2 MOS開關驅動電路設計 18

3.3 微處理器 19

3.4 錳銅電阻電路設計 21

3.5 降壓電路設計 23

3.6 霍爾傳感器濾波電路 24

第４章馬達控制 25

4.1 霍爾傳感器 25

4.1.1 霍爾傳感器介紹 25

4.1.2 霍爾訊號修正 26

4.2 位置估測、速度估測 27

4.2.1 速度估測 27

4.2.2 位置估測 28

第５章空間向量脈波寬度調變 30

5.1 SVPWM導通 30

5.2 SVPWM導通調整 36

5.3 SVPWM導通改良 42

第６章反電動勢分析與改善 47

6.1 無刷馬達反電動勢量測 47

6.2 反電動勢諧波成份分析 49

6.3 SVPWM對應諧波訊號改善 50

第７章測試設備與測量結果 54

7.1 馬達測試設備介紹 54

7.2 硬體電路介紹 55

7.3 效率比較、轉矩輸出 56

7.3.1 效率比較 57

7.3.2 轉矩比較 60

7.4 噪音量測 63

第８章結論 67

8.1 結論 67

8.2 未來展望 67

參考文獻 68

參考文獻

[ 1 ] Jaldanki Sreenivasa Siva Prasad, Gopalaratnam Narayanan, “Minimum switching loss pulse width modulation for reduced power conversion loss in reactive power compensators”, IET Electron. Power Appl., Vol. 7, No. 3, pp.545-551, March 2014.

[ 2 ] Zhao, D., Hari, V.S.S.P.K., Narayanan, G., Ayyanar, R, “Space-vector-based hybrid pulsewidth modulation techniques for reduced harmonic distortion and switching loss”, IEEE Trans. Power Electron., Vol. 25, No. 3, pp. 760–774, March 2010.

[ 3 ] Trzynadlowski, A.M., Legowski, S., “Minimum-loss vector PWM strategy for three-phase inverters”, IEEE Trans. Power Electron., Vol. 9, No. 1, pp. 26–34, January 1994.

[ 4 ] Nguyen, N.V., Nguyen, B.X., Lee, H.H., “An optimized discontinuous PWM method to minimize switching loss for multilevel inverters”, IEEE Trans. Ind. Electron., Vol. 58, No. 9, pp. 3958–3966, September 2011.

[ 5 ] Yunxiang Wu., Shafi, M.A., Knight, A.M., McMohan, R.A., “Comparison of the effects of continuous and discontinuous PWM schemes on power losses of voltage-sourced inverters for induction motor drives”, IEEE Trans. Power Electron., Vol. 26, No. 1, pp. 182–191, January 2011.

[ 6 ] Zhao, D., Narayanan, G., Ayyanar, R., “Switching loss characteristics of sequences involving active state division in space vector based PWM”. Proc. IEEE Applied Power Electronics Conf. (APEC)., Vol. 1, pp. 479–485, February 2004.

[ 7 ] Narayanan, G., Krishnamurthy, H.K., Zhao, D., Ayyanar, R., “Advanced bus-clamping PWM techniques based on space vector approach”, IEEE Trans. Power Electron., Vol. 21, No. 4, pp. 974–984, July 2006.

[ 8 ] Holmes, D.G., Lipo, T.A., “Pulse width modulation for power converters: principles and practice”, Wiley-IEEE Press., Edi. 1, pp. 57-94, 2003.

[ 9 ] Bhavsar, T., Narayanan, G., “Harmonic analysis of advanced bus-clamping PWM techniques”, IEEE Trans. Power Electron., Vol. 24, No. 10, pp. 2347–2352, October 2009.

[ 10 ] Hari, V.S.S., Narayanan, G., “Space vector based hybrid PWM technique to reduce line current distortion in induction motor drives”, IET Power Electron., Vol. 5, No. 8, pp. 1463–1471, September 2012.

[ 11] Basu, K., Siva Prasad, J.S., Narayanan, G., Krishnamurthy, H.K., Ayyanar, R., “Reduction of torque ripple in induction motor drives using an advanced hybrid PWM technique”, IEEE Trans. Ind. Electron., Vol. 57, No. 6, pp. 2085–2091, June 2010.

[ 12] Houldsworth, John A., Grant, Duncan A., “The use of harmonic distortion to increase the output voltage of a three-phase PWM inverter”, IEEE Trans. Ind. Appl., Vol. IA-20, No. 5, pp. 1224–1228, September 1984.

[ 13 ] van der Broeck, H.W., Skudelny, H.-C., “Analytical analysis of the harmonic effects of a PWM ac drive”, IEEE Trans. Power Electron., Vol. 3, No. 2, pp. 216–223, Aprill 1988.

[ 14 ] van der Broeck, H.W., “Analysis of the harmonics in voltage fed inverter drives caused by PWMschemes with discontinuous switching operation”, in Proc. EPE, pp. 261–266, September 1991.

[ 15 ] Fukuda S., Suzuki K., “Harmonic evaluation of two-level carrier-based PWM methods,” in Proc. EPE, pp. 331– 336, September 1997.

[ 16 ] Narayanan G., Ranganathan V. T., “Analytical evaluation of harmonic distortion in PWMAC drives using the notion of stator flux ripple”, IEEE Trans. Power Electron., Vol. 20, No. 2, pp. 466–474, March 2005.

[ 17 ] Wells J. R., Geng X., Chapman P. L., Krein P. T., Nee B. M., “Modulation-based harmonic elimination”, IEEE Trans. Power Electron., Vol. 22, No. 1, pp. 336–340, January 2007.

[ 18 ] Lopes L. A. C., Naguib M. F., “Space vector modulation for low switching frequency current source inverters with reduced low-order noncharacteristic harmonics”, IEEE Trans. Power Electron., Vol. 24, No. 4, pp. 903–910, April 2009.

[ 19 ] Mehrizi-Sani A., Filizadeh S., “An optimized space vector modulation sequence for improved harmonic performance”, IEEE Trans. Ind. Electron., Vol. 56, No. 8, pp. 2894–2903, August 2009.

[ 20 ] 李銘恆，「無刷直流馬達具啟動調整策略之無感測驅動器研製」，國立中央大電機工程學系，碩士論文，民國101年6月。

[ 21 ] Fei Yang, Chenguang Jiang, Taylor A., Hua Bai, “Design of a High-Efficiency Minimum-Torque-Ripple 12-V/1-kW Three-Phase BLDC Motor Drive System for Diesel Engine Emission Reductions”, IEEE Trans. Vehicular techology., Vol. 48, No. 6, pp. 3107–3115, November 2012.

[ 22 ] 詹佳晉，「結合模糊控制並以反電動勢為基礎之無感測永磁同步馬達驅動系統」，國立中央大學電機工程學系，碩士論文，民國102年6月。

[ 23 ] Stirban, A., Boldea I., “Motion-Sensorless Control of BLDC-PM Motor With Offline FEM-Information-Assisted Position and Speed Observer”, IEEE Trans. Industry Applications., Vol. 63, No. 7, pp. 1950–1958, September 2014.

[ 24 ] dsPIC30F5015/5016 Datasheet, Microchip, 2007

[ 25 ] 劉剛編著，「永磁無刷直流電機控制技術與應用」，機械工業出版社，民國97年。

指導教授

徐國鎧(Kuo-Kai Shyu)

審核日期

2015-8-28

推文