以低壓化學氣相沉積成長六方氮化硼薄膜於矽基板其均勻性與時間可靠性之研究

以作者查詢圖書館館藏

、以作者查詢臺灣博碩士

、以作者查詢全國書目

、勘誤回報

、線上人數：14

、訪客IP：3.149.214.60

姓名

韋人豪(Jen-Hao Wei) 查詢紙本館藏

畢業系所

光電科學與工程學系

論文名稱

以低壓化學氣相沉積成長六方氮化硼薄膜於矽基板其均勻性與時間可靠性之研究

相關論文

★ 膜堆光學導納量測儀	★ 以奈米壓印改善陽極氧化鋁週期性
★ 含氫矽薄膜太陽電池材料之光電特性研究	★ 自我複製結構膜光學性質之研究
★ 溫度及應力對高密度分波多工器(DWDM)濾光片中心波長飄移之研究	★ 以射頻磁控濺鍍法鍍製P型和N型微晶矽薄膜之研究
★ 以奈米小球提升矽薄膜太陽能電池吸收之研究	★ 定光電流量測法在氫化矽薄膜特性的研究
★ 動態干涉儀量測薄膜之光學常數	★ 反應式濺鍍過渡態矽薄膜之研究
★ 光子晶體偏振分光鏡之設計與製作	★ 偏壓對射頻濺鍍非晶矽太陽能薄膜特性之研究
★ 負折射率材料應用於抗反射與窄帶濾光片之設計	★ 負電荷介質材料在矽晶太陽電池之研究
★ 自我複製式偏振分光鏡製作與誤差分析	★ 以光激發螢光影像量測矽太陽能電池額外載子生命期及串聯電阻分佈之研究

檔案

[Endnote RIS 格式]

[Bibtex 格式]

[相關文章]

[文章引用]

[完整記錄]

[館藏目錄]

至系統瀏覽論文 (2026-12-30以後開放)

摘要(中)

本研究旨在利用低壓化學氣相沉積法以高溫石英爐管在矽基板上成長六方氮化硼薄膜，發現當沉積時有大量的雜質包含在六方氮化硼薄膜裡，會造成薄膜在大氣下容易剝落，所以我們改善了爐內腔體環境，並使六方氮化硼薄膜在大氣下更加穩定可靠。
在高溫石英爐管內沉積的六方氮化硼薄膜，發現基板位置會嚴重影響薄膜均勻性，也必須要足夠的前驅物來反應，我們最終得到六方氮化硼的拉曼光譜圖半高寬在30~40 cm-1，拉曼特徵峰(E2g 振動模式)在1369~1372 cm-1。

摘要(英)

Hexagonal boron nitride films were grown by using the high-temperature and low-pressure chemical vapor deposition on silicon substrates. When the hexagonal boron nitride films contain a lot of impurities during the deposition, the crack and spalling of the films will be in the atmosphere.
We improved the furnace environment and hexagonal boron nitride films more stable and reliable. The uniformity of the hexagonal boron nitride film deposited in the high-temperature quartz furnace tube was dependent on the position of the substrates and the amount of precursors. Finally, the hexagonal boron nitride films have been achieved successfully with the Raman spectrum full-width at half-maximum of 30~40 cm-1 at the E2g mode of 1369~1372 cm-1.

關鍵字(中)

★ 六方氮化硼
★ 低壓化學氣相沉積

關鍵字(英)

論文目次

目錄
摘要 i
Abstract ii
致謝 iii
目錄 iv
圖目錄 vi
表目錄 ix

第一章緒論 1
1-1前言 1
1-2研究動機 3
第二章基礎理論 4
2-1氮化硼的基本性質 4
2-2硼烷氨(Ammonia brance, AB)特性 6
2-3六方氮化硼製備方式 7
第三章實驗架構與量測儀器介紹 16
3-1實驗儀器 16
爐管系統 16
3-2量測儀器 17
3-2-1 拉曼光譜儀(Raman) 17
3-2-2 X射線光電子能譜儀(X-ray photoelectron spectroscopy，XPS) 19
3-2-3 傅立葉轉換紅外光譜儀(Fourier-transform infrared spectroscopy, FTIR) 20
3-3 六方氮化硼製作流程方法與製程參數 22
第四章實驗結果 26
4-1 六方氮化硼薄膜成長分析 26
4-1-1製程環境改進 26
4-1-2前驅物硼烷氨之影響 26
4-1-3製程氣體比例之影響 30
4-1-4製程時間之影響 30
4-1-5均勻性分析 36
4-1-6 XPS量測 44
4-2 六方氮化硼可靠性分析 48
第五章結論與未來研究 55
5-1 結論 55
5-2 未來研究 55
參考文獻 56

參考文獻

[1] K. S. Novoselov, A.K. Geim, S.V. Morozov, D. Jiang, Y. Zhang, S.V. Dubonos, I.V. Grigorieva, A.A. Firsov, “Electric Field Effect in Atomically Thin Carbon Films”, Science. 306. 666-669. 2004.
[2] 黃松勳, “二維材料的發展與應用進程”, 科技政策觀點, 2018. https://portal.stpi.narl.org.tw/index/article/10409
[3] K. K. Kim, A. Hsu, X. Jia, S. M. Kim, Y. Shi, M. Hofmann, D. Nezich, J. F. R. Nieva, M. Dresselhaus, T. Palacios, and J. Kong, “Synthesis of Monolayer Hexagonal Boron Nitride on Cu Foil Using Chemical Vapor Deposition”, Nano Lett. 12. 161-166. 2012.
[4] V. L. Solozhenkoa, A. G. Lazarenkob, J. P. Petitetb , A. V. Kanaev, “Bandgap energy of graphite-like hexagonal boron nitride”, J Phys Chem Solids. 62. 1331-1334. 2001.
[5] L. Song, L. Ci, H. Lu, P. B. Sorokin, C. Jin, J. Ni, A.r G. Kvashnin, D. G. Kvashnin, J. Lou, B. I. Yakobson, P. M. Ajayan, “Large Scale Growth and Characterization of Atomic Hexagonal Boron Nitride Layers”, Nano Lett. 10. 3209–3215. 2010.
[6] G. Kim, A. R. Jang, H. Y. Jeong, Z. Lee, D. J. Kang, H. S. Skin, “Growth of High-Crystalline Single-Layer Hexagonal Boron Nitride on Recyclable Platinum Foil”, Nano Lett. 13. 1834-1839. 2013.
[7] T. A. Chen, C. P. Chuu, C. C. Tseng, C. K. Wen, H. S. P. Wong, S. Pan, R. Li, T. A. Chao, W. C. Chueh, Y. Zhang, Q. Fu, B. I. Yakobson, W. H. Chang, L. J. Li, “Wafer-scale single-crystal hexagonal boron nitride monolayers on Cu (111)”, Nat. 579. 219. 2020.
[8] M. Jana, R. N. Singh, “Progress in CVD synthesis of layered hexagonal boron nitride with tunable properties and their applications”, Int. Mater. Rev. 63. 162-203. 2018.
[9] J. Zhang, B. Tan, X. Zhang, F. Gao, Y. Hu, L. Wang, X. Duan, Z. Yang, and P. Hu, “Atomically Thin Hexagonal Boron Nitride and Its Heterostructures”, Adv. Mater. 33. 2020.
[10] H. Quan, X. Wang, L.Zhang, N. Liu, S. Feng , Z. Chen, L. Hou, Q. Wang, X. Liu , J. Zhao , Y. Gao , G. Jia, “Stability to moisture of hexagonal boron nitride films deposited on silicon by RF magnetron sputtering”, Thin Solid Films. 645. 90-95. 2017.
[11] C. B. Samantaray, R. N. Singh, “Review of synthesis and properties of cubic boron nitride (c-BN) thin films”, Int. Mater. Rev. 50. 313-344. 2005.
[12] 氮化硼wiki, 2021.
https://zh.wikipedia.org/wiki/%E6%B0%AE%E5%8C%96%E7%A1%BC
[13] R. Geick, C. H. Perry, “ Normal modes in hexagonal boron nitride”, Phys. Rev. 146. 543-547. 1966.
[14] M. J. Rand, J. F. Roberts, “Preparation and Properties of Thin Film Boron Nitride”, J. Electrochem. Soc. 115. 423. 1968.
[15] N. Mohajeri, A. T-Raissi, “Regeneration of Ammonia-Borane Complex for Hydrogen Storage”, Mater. Res. Soc. Symp. Proc. 884E. 2005.
[16] G. Wolf, J. Baumanna, F. Baitalowa, F. P. Hoffmann, “Calorimetric process monitoring of thermal decomposition of B-N-H compounds”, Thermochimica Acta. 343. 19-25. 2000.
[17] M. G. Hu, R. A. Geanangel, W. W. Wendlandt, “The thremal decomposition of ammonia borane”, Thermochimica Acta. 23. 249-255. 1978.
[18] S. Frueh, R. Kellett, C. Mallery, T. Molter, W S. Willis, C. King’ondu, and S. L. Suib, “ Pyrolytic Decomposition of Ammonia Borane to Boron Nitride”, Inorg. Chem. 50. 783-792. 2011.
[19]李正中, “薄膜光學與鍍膜技術”,第八版. 292-317. 2016.
[20] Q. Li, Q. Zhang, Y. Bai, H. Zhang, P. Hu, Y. Li, and . Yun, “Deep-UV hexagonal boron nitride (hBN)/BAlN distributed Bragg reflectors fabricated by RF-sputtering”, Opt. Mater. Express. 11. 180-188 2021.
[21] H. Liu, J. Meng, X. Zhang, Y. Chen, Z. Yin, D. Wang, Y. Wang, J. You, M. Gao, P. Jin, “High-performance deep ultraviolet photodetectors based on few-layer hexagonal boron nitride”, Nanoscale. 10. 5559-5565. 2018.
[22] C. Go´mez-Aleixandre, A. Essafti, M. Ferna´ndez, J. L. G. Fierro, and J. M. Albella, “Influence of Diborane Flow Rate on the Structure and Stability of CVD Boron Nitride Films”, J. Phys. Chem. 100. 2148-2153. 1996.
[23] K. Ba, W. Jiang, J. Cheng, J. Bao, N. Xuan, Y. Sun, B. Liu, A. Xie, S. Wu and Z. Sun, “Chemical and Bandgap Engineering in Monolayer Hexagonal Boron Nitride”, Sci. Rep. 7. 45584. 2017.
[24] T. C. Doan, S. Majety, S. Grenadier, J. Li, J.Y. Lin, H.X. Jiang, “Hexagonal boron nitride thin film thermal neutron detectors with High energy resolution of the reaction products” , Cretac Res. 783. 121-127. 2015.
[25] S. Sharma, K. Sharma, M. S. Rosmi, Y. Yaakob, M. I. Araby, H. Ohtani, G. Kalita, and M. Tanemura, “Morphology-Controlled Synthesis of Hexagonal Boron Nitride Crystals by Chemical Vapor Deposition”, Cryst. Growth Des. 16. 6440-6445. 2016.
[26] 佐信科技有限公司，拉曼光譜分析原理, 2021.
https://www.protrustech.com/show/show-558351.htm
[27] Edinburgh instruments, what is Raman spectroscopy?
https://www.edinst.com/blog/what-is-raman-spectroscopy/
[28] X射線光電子能譜儀,wiki, 2021.
https://zh.wikipedia.org/wiki/X%E5%B0%84%E7%BA%BF%E5%85%89%E7%94%B5%E5%AD%90%E8%83%BD%E8%B0%B1%E5%AD%A6
[29] Y. Shi, C. Hamsen, X. Jia, K. K. Kim, A. Reina, M. Hofmann, A. L. Hsu, K. Zhang, H. Li, Z. Y. Juang, M. S. Dresselhaus, L. J. Li, and J. Kong, “Synthesis of Few-Layer Hexagonal Boron Nitride Thin Film by Chemical Vapor Deposition”, Nano Lett. 10. 4134-4139. 2010.
[30] 國立中央大學貴重儀器使用中心 XPS, 2021.
https://vir.most.gov.tw/VI_SearchResult?center=8A818346-1E15-CEA6-011E-15D1ADA70011
[31] Y. C. Lee, C. I. Chen,“高解析傅立葉轉換紅外光譜顯微術之原理與應用”,科儀新知第二十七卷第三期 94.12.
[32] Y. Li, J. Guo, W. Zheng, and F. Huang “Amorphous boron nitride for vacuum-ultraviolet photodetection”, Appl. Phys. Lett. 117. 023504. 2020.
[33]“FTIR的採樣技術因應各類型樣品而生”, 新國科技公司, 2021.
http://www.scinco.tw/support/technical_02.asp
[34] Y. L. Chien “Nucleation and growth kinetics of hexagonal boron nitride growth on copper substrate in chemical vapor deposition”, 國立中央大學, 中華民國108年6月
[35] K. Ahmed, R. Dahal, A. Weltz, J. Q. Lu, Y. Danon, I. B. Bhat, “Growth of hexagonal boron nitride on (111) Si for deep UV photonics and thermal neutron detection”, Appl. Phys. Lett. 109. 113501. 2016.
[36] 李嘉鳴“以電漿氮化高參雜硼矽(111)基板之方式磊晶成長六方氮化硼薄膜”, 國立成功大學, 中華民國102年7月.
[37] Dmitri Petrovykh, “Si (111) Surface”, Silicon Nanoworld. 2021.
https://nanowiz.tripod.com/sisteps/si111.htm

指導教授

陳昇暉(Sheng-Hui Chen)

審核日期

2021-12-28

推文