永磁同步馬達之低電流諧波及霍爾感測器容錯控制

以作者查詢圖書館館藏

、以作者查詢臺灣博碩士

、以作者查詢全國書目

、勘誤回報

、線上人數：86

、訪客IP：3.133.133.189

姓名

劉繼駿(Chi-Chun Liu) 查詢紙本館藏

畢業系所

電機工程學系

論文名稱

永磁同步馬達之低電流諧波及霍爾感測器容錯控制
(Hall Sensor Fault Tolerant Control for Permanent Magnet Synchronous Motor with Low Current Harmonic)

相關論文

★ 感光式觸控面板設計	★ 單級式直流無刷馬達系統之研製
★ 單級高功因LLC諧振電源轉換器之研製	★ 多頻相位編碼於穩態視覺誘發電位之大腦人機介面系統設計
★ 類神經網路於切換式磁阻馬達轉矩漣波控制之應用	★ 感應馬達無速度感測之直接轉矩向量控制
★ 具自我調適導通角度功能之切換式磁阻馬達驅動系統---DSP實現	★ 感應馬達之低轉速直接轉矩控制策略
★ 加強型數位濾波器設計於主動式噪音控制之應用	★ 非匹配不確定可變結構系統之分析與設計
★ 無刷直流馬達直接轉矩控制方法之轉矩漣波改善	★ 無轉軸偵測元件之無刷直流馬達驅動器研製
★ 無轉軸偵測元件之開關磁阻馬達驅動系統研製	★ 感應馬達之新型直接轉矩控制研究
★ 同步磁阻馬達之性能分析及運動控制研究	★ 改良比例積分與模糊控制器於線性壓電陶瓷馬達位置控制

檔案

[Endnote RIS 格式]

[Bibtex 格式]

[相關文章]

[文章引用]

[完整記錄]

[館藏目錄]

至系統瀏覽論文 (2027-7-21以後開放)

摘要(中)

本論文提出了一種結合霍爾感測器容錯控制與抑制電流諧波的方法用於永磁同步馬達驅動。此研究使用霍爾感測器估測轉子位置，並實現霍爾感測器容錯控制及優化估測角度的方法，以提高永磁同步馬達驅動的安全性、可靠性。文中分析霍爾訊號的狀態及發生狀態變化時的轉子位置訊息以及三相霍爾訊號之間的對應關係，以任一相霍爾訊號狀態發生變化時，觀察另外一相霍爾訊號的狀態值，將其結果和該相霍爾訊號前一次變化時所觀察到的狀態值進行比較，兩者的異同將作為是否發生故障的依據，藉此提出一個有效且簡易的故障診斷方法，在此基礎上，排除故障感測器所產生的錯誤位置訊號，使用剩餘正常的霍爾訊號對轉子位置進行估測，同時霍爾感測器會因為缺少某些片段的位置資訊，使轉子估測的精確度伴隨著解析度降低而降低，進而影響對馬達控制效率，因此藉由同步頻率追蹤濾波器(SFTF)提取估測角度的基本波並消除高頻雜訊，使霍爾感測器發生故障時仍保有精確的轉子位置。控制方法則使用線性主動抗擾控制(Linear Active Disturbance Rejection Control)，由線性擴展狀態觀測器 (Linear extended state observers) 和一個比例電流控制器組成，利用狀態觀察器估測電流擾動，估測的總擾動經由電流控制迴路進行前饋補償，可以有效的降低電流諧波並提升流經設備的電流品質以及系統的穩定性。

摘要(英)

A method combines Hall sensor fault-tolerant control and linear active disturbance rejection controller (LADRC) for the permanent magnet synchronous motor (PMSM) drivers is proposed in this article. This research uses the Hall sensor as the rotor position sensor. Hall sensor fault-tolerant control consists of sensor fault diagnosis and optimized estimation angle to improve the safety and reliability of system. The section of sensor fault diagnosis analyzes the relationship between the state of the Hall signal and the rotor position. When the state of the Hall signal changes, it samples the state value of the other Hall signal and compare with the state value sampled from the previous change. The similarities and differences between the two value will be used as the basis for failure. On this basis, the wrong position signal generated by the fault sensor is eliminated, and the remaining Hall signal is used to estimate the rotor position. The section of optimized estimation angle method is to extract the fundamental wave of the estimated angle and eliminate the high frequency noise by the Synchronous Frequency Tracking Filter (SFTF), so that the accurate rotor position is maintained even when the Hall sensors fail.
In the part of Linear Active Disturbance Rejection Control, it consists of linear extended state observer (LESO) and a proportional current controller. LESO is designed to estimate the external disturbance. The estimated disturbance is used as a feedforward compensation term in the current control loop to improve the current regulation quality and the stability of the system.

關鍵字(中)

★ 永磁同步馬達
★ 線性擴展狀態觀測器
★ 線性主動抗擾控制
★ 同步頻率追蹤濾波器
★ 霍爾感測器

關鍵字(英)

★ linear extended state observer
★ linear active disturbance rejection control
★ permanent magnet synchronous motor
★ Synchronous Frequency Tracking Filter
★ Hall sensor

論文目次

摘要 I
ABSTRACT II
誌謝 III
目錄 IV
表目錄 VI
圖目錄 VII
第一章緒論 1
1-1 研究動機與目的 1
1-2 大綱 3
第二章同步馬達介紹 4
2-1 前言 4
2-2 永磁同步馬達簡介 5
第三章控制系統之硬體架構介紹 10
3-1 前言 10
3-2 電源模組電路 11
3-3 電流感測電路 13
3-4 微控制器及周邊電路 14
3-5 功率開關及驅動電路 15
第四章霍爾位置感測器容錯控制 17
4-1 霍爾感測器原理介紹 17
4-1-1 霍爾效應 17
4-1-2 霍爾感測器 18
4-2 霍爾感測器故障診斷、補償及優化 19
4-2-1 故障情況分析 19
4-2-2 基於霍爾狀態及狀態變化之故障檢測 20
4-2-3 正常、故障情況下速度及角度估測 22
4-2-4 同步頻率追蹤濾波器 25
第五章馬達控制方法 29
5-1 前言 29
5-2 線性主動抗擾控制 31
5-2-1 基於線性主動抗擾控制之磁場導向控制 31
5-2-2 永磁同步馬達模型及電流諧波模型 32
5-2-3 線性主動抗擾控制 34
5-2-4 觀察器參數分析 36
5-2-5 模擬結果與分析 37
第六章實驗結果 41
6-1 實驗架構 41
6-2 霍爾感測器容錯方法之實驗結果 42
6-3 馬達控制方法之實驗結果 50
第七章結論與未來展望 60
參考文獻 61

參考文獻

[1] J. Lara, J. Xu, and A. Chandra, "Effects of Rotor Position Error in the Performance of Field-Oriented-Controlled PMSM Drives for Electric Vehicle Traction Applications," in IEEE Transactions on Industrial Electronics, vol. 63, no. 8, pp. 4738-4751, Aug. 2016.
[2] J. Hu, J. Zou, F. Xu, Y. Li, and Y. Fu, "An Improved PMSM Rotor Position Sensor Based on Linear Hall Sensors," in IEEE Transactions on Magnetics, vol. 48, no. 11, pp. 3591-3594, Nov. 2012.
[3] 潘盈君，「無感測器無刷直流馬達驅動系統具啟動策略之研究」，國立中央大學電機工程學系，碩士論文，民國 104 年 6 月。
[4] D. Liang, J. Li, R. Qu, and W. Kong, "Adaptive Second-Order Sliding-Mode Observer for PMSM Sensorless Control Considering VSI Nonlinearity," in IEEE Transactions on Power Electronics, vol. 33, no. 10, pp. 8994-9004, Oct. 2018.
[5] H. Kim, J. Son, and J. Lee, "A High-Speed Sliding-Mode Observer for the Sensorless Speed Control of a PMSM," in IEEE Transactions on Industrial Electronics, vol. 58, no. 9, pp. 4069-4077, Sept. 2011.
[6] 杜冠頡，「創新式高頻注入法應用於無感測永磁同步馬達驅動」，國立中央大學電機工程學系，碩士論文，民國 107 年 6 月。
[7] S. Wang, K. Yang, and K. Chen, "An Improved Position-Sensorless Control Method at Low Speed for PMSM Based on High-Frequency Signal Injection into a Rotating Reference Frame," in IEEE Access, vol. 7, pp. 86510-86521, 2019.
[8] X. Luo, Q. Tang, A. Shen, and Q. Zhang, "PMSM Sensorless Control by Injecting HF Pulsating Carrier Signal Into Estimated Fixed-Frequency Rotating Reference Frame," in IEEE Transactions on Industrial Electronics, vol. 63, no. 4, pp. 2294-2303, April 2016.
[9] 孫煒竣，「低解析度位置感測器用於永磁同步馬達之直接轉矩控制」，國立中央大學電機工程學系，碩士論文，民國 109 年 6 月。
[10] G. Liu, B. Chen, and X. Song, “High-precision speed and position estimation based on Hall vector frequency tracking for PMSM with bipolar Hall-effect sensors,” IEEE Sens. J., vol. 19, no. 6, pp. 2347-2355, Mar. 2019.
[11] 鍾嘉倫，「改良轉子位置估測之永磁同步馬達直接轉矩控制」，國立中央大學電機工程學系，碩士論文，民國 109 年 6 月。
[12] X. Zhang and W. Zhang, "An improved rotor position estimation in PMSM with low-resolution hall-effect sensors," 2014 17th International Conference on Electrical Machines and Systems (ICEMS), 2014, pp. 2722-2727.
[13] L. Dong and J. Liu, "Fault Detection and Fault Tolerant Control of Permanent Magnet Synchronous Motor Drives with Hall Sensors[J]," Journal of Northwestern Polytechnical University, 2016, 34(2): 306-312.
[14] W. Liang, J. Wang, P. C. Luk, W. Fang, and W. Fei, "Analytical Modeling of Current Harmonic Components in PMSM Drive With Voltage-Source Inverter by SVPWM Technique," in IEEE Transactions on Energy Conversion, vol. 29, no. 3, pp. 673-680, Sept. 2014.
[15] 野力電機，YBL9D 系列伺服馬達規格特性表與外型尺寸圖，取自 http:/ /www.yeli.com.tw/download/20130409114647.pdf
[16] Texas Instruments，LM2575HV/LM2575ADJ datasheet，取自 http://w ww.ti.com/lit/ds/symlink/lm2575-n.pdf
[17] STMicroelectronics，STM32F103R8 datasheet，取自https://www.s t.com/r so-urc-e/en/datasheet/stm32f103c8.pdf
[18] O. Lingberg, “Hall Effect,” Proc. IRE, vol. 40, no. 11, pp. 1414-1419, Nov. 1952.
[19] C. Gong, Y. Hu, J. Gao, Y. Wang, and L. Yan, "An Improved Delay-Suppressed Sliding-Mode Observer for Sensorless Vector-Controlled PMSM," in IEEE Transactions on Industrial Electronics, vol. 67, no. 7, pp. 5913-5923, July 2020,
[20] H. Zhang, W. Liu, Z. Chen, G. Luo, J. Liu, and D. Zhao, "Asymmetric Space Vector Modulation for PMSM Sensorless Drives Based on Square-Wave Voltage-Injection Method," in IEEE Transactions on Industry Applications, vol. 54, no. 2, pp. 1425-1436, March-April 2018.
[21] 王儷融，「無感測器馬達初始位置估測及啟動方法實現」，國立中央大學電機工程學系，碩士論文，民國 105 年 6 月。
[22] 蔡和興，「電動車之煞車回充研究與驅動器設計」，國立中央大學電機工程學系，碩士論文，民國 104 年 6 月。
[23] 劉昌煥，交流電機控制，第四版，東華書局，民國 97 年 7 月。
[24] T.-C. Jeong, W.-H. Kim, M.-J. Kim, K.-D. Lee, J.-J. Lee, J.-H. Han, T.-H. Sung, H.-J. Kim, and J. Lee, “Current harmonics loss analysis of 150-kW traction interior permanent-magnet synchronous motor through co-analysis of d − q axis current control and finite element method,” IEEE Trans. Magn., vol. 49, no. 5, pp. 2343–2346, May 2013.
[25] C. Lai, G. Feng, K. Mukherjee, V. Loukanov, and N. C. Kar, “Torque ripple minimization for interior PMSM with consideration of magnetic saturation incorporating online parameter identification,” IEEE Trans. Magn., vol. 53, no. 6, pp. 1–4, Jun. 2017.
[26] W. Wang, C. Liu, S. Liu, Z. Song, H. Zhao, and B. Dai, "Current Harmonic Suppression for Permanent-Magnet Synchronous Motor Based on Chebyshev Filter and PI Controller," in IEEE Transactions on Magnetics, vol. 57, no. 2, pp. 1-6, Feb. 2021.
[27] G. Liu, B. Chen, K. Wang, and X. Song, "Selective Current Harmonic Suppression for High-Speed PMSM Based on High-Precision Harmonic Detection Method," in IEEE Transactions on Industrial Informatics, vol. 15, no. 6, pp. 3457-3468, June 2019.
[28] J. Xu and H. Zhang, "Random Asymmetric Carrier PWM Method for PMSM Vibration Reduction," in IEEE Access, vol. 8, pp. 109411-109420, 2020.
[29] L. Qu, W. Qiao, and L. Qu, "An Enhanced Linear Active Disturbance Rejection Rotor Position Sensorless Control for Permanent Magnet Synchronous Motors," in IEEE Transactions on Power Electronics, vol. 35, no. 6, pp. 6175-6184, June 2020.
[30] G. Zhang, G. Wang, B. Yuan, R. Liu, and D. Xu, "Active Disturbance Rejection Control Strategy for Signal Injection-Based Sensorless IPMSM Drives," in IEEE Transactions on Transportation Electrification, vol. 4, no. 1, pp. 330-339, March 2018.
[31] J. Han, ‘‘Auto-disturbances-rejection controller and its applications,’’ Control Decis., vol. 1, pp. 19–23, Jan. 1998.
[32] J. Han, “From PID to active disturbance rejection control,” IEEE Trans. Ind. Electron., vol. 56, no. 3, pp. 900–906, Mar. 2009.
[33] X. Yang and Y. Huang, "Capabilities of extended state observer for estimating uncertainties," 2009 American Control Conference, 2009, pp. 3700-3705.
[34] Z. Gao, "Scaling and bandwidth-parameterization based controller tuning," Proceedings of the 2003 American Control Conference, 2003., 2003, pp. 4989-4996.

指導教授

徐國鎧(Kuo-Kai Shyu)

審核日期

2022-7-28

推文