具顆粒阻尼器引擎轉軸振動抑制的實驗研究;Experimental study on vibration suppression of engine shafts with particle damper

NCU Institutional Repository > 工學院 > 機械工程學系碩士在職專班 > 博碩士論文 > Item 987654321/95867

jsp.display-item.identifier=請使用永久網址來引用或連結此文件: http://ir.lib.ncu.edu.tw/handle/987654321/95867

题名:	具顆粒阻尼器引擎轉軸振動抑制的實驗研究;Experimental study on vibration suppression of engine shafts with particle damper
作者:	吳豈洋;Wu, Chi-Yang
贡献者:	機械工程學系在職專班
关键词:	引擎轉軸;動平衡校正;顆粒阻尼器;雙面平衡法;振動抑制;顆粒粒徑效益;Engine shaft;Dynamic balance correction;Particle damper;Double plane balance method;Vibration suppression;Particle Size effect
日期:	2024-07-18
上传时间:	2024-10-09 17:21:08 (UTC+8)
出版者:	國立中央大學
摘要:	當旋轉機械系統內部的轉動件具有不平衡質量時，在轉動過程中會引起振動，長久下造成機械系統產生噪音損害與降低使用壽命。本研究將顆粒阻尼器應用於引擎轉軸來校正動平衡狀態，同時顆粒阻尼器中顆粒與壁面間的碰撞與摩擦抑制旋轉機械系統的振動，達到動平衡校正兼具抑制振動的效果，為探討顆粒阻尼器對抑制振動的效益，實驗中設計等效質量無顆粒阻尼器引擎轉軸與具顆粒阻尼器引擎轉軸，在兩者皆達到動平衡校正至ISO1940 動平衡規格G2.5 等級以下，且達相近的動平衡允許值後，比較等效質量無顆粒阻尼器引擎轉軸與具顆粒阻尼器引擎轉軸的動態反應，探討工作轉速、負載扭矩與顆粒粒徑對引擎轉軸動態反應的影響，其中分析的動態反應物理量包含時域訊號中加速度的方均根值、頻域訊號中的功率譜密度與單位質量的動能。研究結果顯示： (1)在頻域訊號的比較中，各轉速下功率譜密度與單位質量的動能的一倍頻率中，具顆粒阻尼器引擎轉軸相較於等效質量無顆粒阻尼器引擎轉軸皆來得低，說明具顆粒阻尼器引擎轉軸兼具動平衡校正與抑制振動的效果； (2) 透過振動訊號分析，觀察工作轉速與負載扭矩對引擎轉軸動態行為的影響，在低轉速及低扭矩、高轉速及高扭矩的組合中，各粒徑顆粒阻尼器引擎轉軸相較等效質量無顆粒阻尼器引擎轉軸的振動降幅比具有顯著的減振效果，但φ4 mm 顆粒阻尼器引擎轉軸在高轉速及高扭矩的組合中，減振效果呈現降低的趨勢； (3)透過振動訊號分析，觀察顆粒粒徑對引擎轉軸的影響，探討的粒徑包含φ2 mm、φ3 mm 與φ4 mm，其中φ2 mm 顆粒阻尼器引擎轉軸具有最穩定且顯著的抑振表現； (4)通過本實驗驗證，在顆粒阻尼器中填充適當粒徑的顆粒，並做好動平衡校正，可有效降低引擎轉軸的振動。;When the rotating parts inside the rotating mechanical system have an unbalanced mass, vibration will be caused during the rotation process, leading to noise damage and reducing service life of the mechanical system in the long run. In this study, a particle damper is applied to the engine shaft to correct the dynamic balance state. At the same time, the collision and friction between the particles and the wall in the particle damper suppress the vibration of the rotating mechanical system, achieving the effect of dynamic balance correction and vibration suppression. To explore the effectiveness of particle damper in suppressing vibrations, the engine shafts designed with equivalent mass without particle dampers and the engine shafts with particle dampers both achieved dynamic balance correction to the G2.5 level in ISO1940 dynamic balance specification, attaining similar dynamic balance allowances. After dynamic balance, the dynamic response of the two kinds of engine shafts were compared, and the effects of operating speed, load torque and particle size on the dynamic response of the engine shaft were systematically explored. The dynamic physical properties include the root mean square value of the acceleration in the time domain signal, the power spectral density and energy in the frequency domain signal. The research findings are summarized below: (1) In the comparison excitation frequency of frequency domain signals, at each speed, the power spectral density and energy of the engine shaft with particle dampers are lower than those in the engine shaft with equivalent mass without particle dampers, showing that the particle damper provides the effect of vibration suppression; (2) At low speed with low torque and high speed with high torque, the engine shaft with particle dampers relative to the engine shaft with equivalent mass without particle damper has a significant vibration reduction effect. However, at low speed with low torque, the vibration reduction effect of particle damper with 4 mm particles shows a decreasing trend; (3) The effect of particle size was explored and three kinds of particle diameters (2 mm, 3 mm and 4 mm) were used. The particle damper with 2 mm particles exhibits the most stable and significant performance in vibration suppression; (4) Through experimental validation, by using particles of appropriate particle size and conducting dynamic balance correction, the particle dampers can reduce the vibration of the engine shaft effectively.
显示于类别:	[機械工程學系碩士在職專班 ] 博碩士論文

文件中的档案:

档案	描述	大小	格式	浏览次数
index.html		0Kb	HTML	36	检视/开启

在NCUIR中所有的数据项都受到原著作权保护.

社群 sharing

数据加载中.....